Rocker Arm and Shaft - Install
Show/hide table
| 所需工具 | |||
|---|---|---|---|
| 工具 | 零件号 | 零件描述 | 数量 |
| A | 124-2946 | 提升支架 | 1 |
Show/hide table
| 注意 |
|---|
|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
- 用工具 (A) 把摇臂轴组件 (4)、气门摇臂 (3) 以及电子单体喷油器摇臂 (1) 作为一个整体安置到缸盖上。
注: 安装之前，将清洁的发动机机油涂抹在螺栓头的下部。
- 安装螺栓 (2) 并拧紧至扭矩
55 ± 5 N·m (41 ± 4lb ft) ，再转动 60 ± 5 度。 按照以下顺序拧紧螺栓：2、3、4、1。 - 调整进气阀和排气阀的阀间隙。 请参阅测试和调整, "发动机气门间隙 - 检查/调整"。
- 调整电子单体喷油器。 请参阅测试和调整, "电子单体喷油器 - 调整"。
Show/hide table
| |
| 图 1 | g01188378 |
Show/hide table
| |
| 图 2 | g01325993 |
结束:
- 安装气门机构盖。 请参阅拆解和组装, "气门机构盖 - 拆卸和安装"。
Caterpillar Information System:
C9-XQ300 Rental Generator Set Engine Speed/Timing Sensors - Check/Clean/Calibrate
C32 Marine Engines Rocker Arm and Shaft - Remove
C13, C15, and C18 Tier 4 Final Engines Valve Mechanism
C32 Marine Engines Valve Mechanism Cover Base - Remove and Install
3412E and C30 Marine Engines Fuel System Water Separator - Drain
C4.4 and C6.6 Industrial Engines and Engines for Caterpillar Built Machines CID 1779 FMI 06
C4.4 and C6.6 Engines for Caterpillar Built Machines Engine Speed/Timing Sensor Circuit - Test
C27 and C32 Generator Set Engines Vibration Damper and Pulley
C32 Marine and Auxiliary Marine Engines Valve Mechanism Cover - Remove and Install
C32 Marine and Auxiliary Marine Engines Housing (Rear) - Install
345C MHPU Mobile Hydraulic Power Unit Engine Supplement Muffler - Remove and Install
C32 Marine and Auxiliary Marine Engines Housing (Rear) - Remove
345C MHPU Mobile Hydraulic Power Unit Engine Supplement Exhaust Manifold - Remove and Install
C11 and C13 On-Highway Engines Turbocharger
C11 and C13 On-Highway Engines Air Lines
C27 and C32 Generator Set Engines Flywheel
C11 and C13 On-Highway Engines Camshaft
C15 Petroleum Generator Set Engines Alternator and Regulator
2005/08/15 New Bolt Available to Secure Generator Flex-Plate to Generator Rotor Shaft {3252}
C6.6 Engines for Caterpillar Built Machines Air Inlet and Exhaust System
3126B Generator Set Engine Diagnostic Codes
2005/08/29 A New O-Ring Seal is Now Available for the Crankcase Breather {1317}
C11 and C13 Industrial Engines Engine Oil Filter Base
345C MHPU Mobile Hydraulic Power Unit Engine Supplement Turbocharger - Remove