Gear Pump (Rear Axle Oil) - Remove
Start By:
- Remove the differential and bevel gear. Refer to Disassembly and Assembly, "Differential and Bevel Gear - Remove".
- Remove four twelve point bolts (3) and the washers in order to remove tube assembly (1) and the O-ring seal from gear pump (2).
- Remove four twelve point bolts (4) and the washers in order to remove tube assembly (5) and the O-ring seal from gear pump (2).
Show/hide table
Illustration 3 g00567187 Show/hide table
Illustration 4 g00567188 - Remove four bolts (6) and the washers in order to remove gear pump (2) from the differential carrier assembly.
- Remove shims (7) from the differential carrier assembly.
Show/hide table
Illustration 5 g00567189 - Remove cotter pin (8) in order to remove slotted nut (10).
- Remove slotted nut (10) and the washer in order to remove gear (9) from gear pump (2).
Note: Put identification marks on all hose assemblies and on all tube assemblies for installation purposes. Plug all hose assemblies and all tube assemblies. This helps to prevent fluid loss and this helps to keep contaminants from entering the system.
Note: Cleanliness is an important factor. Before the removal procedure, the exterior of the component should be thoroughly cleaned. This will help to prevent dirt from entering the internal mechanism.
Show/hide table
| |
| Illustration 1 | g00567184 |
Show/hide table
| |
| Illustration 2 | g00567185 |
Caterpillar Information System:
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Mode 8 - EMC Lamp Test
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems F421 Battery Voltage at EMC - Low
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems F420 Alternator - Overcharging
3054 Engine for Caterpillar Built Machines Rocker Shaft and Pushrod - Install
Challenger 65E, Challenger 75E, Challenger 85E and Challenger 95E Agricultural Tractors Implement, Steering and Brake Hydraulic Systems Troubleshooting
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Mode 7 - CCM Transmission Control Output Diagnostics
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems F419 Alternator - Not Charging
CB-634C Vibratory Compactor Operator Platform Swivel
416C, 426C, 428C, 436C and 438C Backhoe Loaders Hydraulic and Steering System Pump Flow - Test
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems F418 Coolant Level Status
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems F417 Air Filter Status
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Machine Systems Pump Drive - Disassemble
Challenger 65E, Challenger 75E, Challenger 85E and Challenger 95E Agricultural Tractors Power Train Track Alignment
CB-634C Vibratory Compactor Seat
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems F422 Connector C008 - Open
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Mode 9 - Hardware/Software Revision Level
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Machine Systems Pump Drive - Assemble
784C and 785C Off-Highway Truck Power Train Gear Pump (Rear Axle Oil) - Install
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems No. 1 Auxiliary Relay - Troubleshoot
416C, 426C, 428C, 436C and 438C Backhoe Loaders Hydraulic and Steering System Load Control Valve (Boom or Stick)
3116 Engine for Challenger 35, and Challenger 45 Agricultural Tractors and 3126 Engine for Challenger 55 Agricultural Tractor Engine Supplement Air Conditioner Receiver/Dryer - Remove and Install
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Mode 10 - Transmission Calibration Review and Programming
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems No. 2 Auxiliary Relay - Troubleshoot
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Transmission Power Relay - Troubleshoot