Some Reman Injectors Have Been Labeled With The Incorrect Part Number{1254, 1290}
- Asphalt Paver:
- AP-1000D (S/N: EAD1-UP)
- AP-1055D (S/N: FAC1-UP; A6P1-UP)
- BG-2455D (S/N: BNW1-UP; BXW1-UP)
- BG-260D (S/N: BPW1-UP)
- AP-1055D (S/N: FAC1-UP; A6P1-UP)
- Engine:
- C7 (S/N: RMF1-UP; TSK1-UP; FML1-UP; JKL1-UP; KAL1-UP; FMM1-UP; SAP1-UP; JRT1-UP; WAX1-UP; PRY1-UP)
- Truck Engines:
- C7 TRUCK ENGINE (S/N: LBM1-UP)
- C7 TRUCK/BUS (S/N: YPG1-UP)
- Excavator:
- 324D L (S/N: DFP1-UP)
- 325D L (S/N: GPB1-UP)
- 325D LN (S/N: PKE1-UP)
- 325D L (S/N: AZP1-UP; SCR1-UP; CYW1-UP)
- 325D L (S/N: GPB1-UP)
- Integrated Toolcarrier:
- IT62H (S/N: M5G1-UP)
- Wheel Loader:
- 950H (S/N: N1A1-UP; M1G1-UP; K5K1-UP)
- 962H (S/N: N4A1-UP; M3G1-UP; K6K1-UP)
- Wheel Skidder:
- 535C (S/N: 5351-UP)
Introduction
The problem that is identified below does not have a known permanent solution. Until a permanent solution is known use the solution that is identified below.
Problem
The Reman Injectors in Table 1 were labeled with an incorrect part number.
Using one of the mislabeled injector could cause engine performance issues.
Show/hide table
Part Number     | Serial Number     |
10R-4761     | B3105257783D     |
10R-4761     | B310547277B7     |
10R-4761     | B310547359DC     |
10R-4761     | B3105479674E     |
10R-4761     | B31055358875     |
10R-4761     | B3105692799D     |
10R-4761     | B310570174C7     |
10R-4761     | B310585952D0     |
10R-4761     | B310589411F4     |
10R-4761     | B31059067584     |
10R-4761     | B31059279931     |
10R-4761     | B310609354CF     |
10R-4761     | B310620090F0     |
10R-4761     | B310620401E1     |
10R-4761     | B31062590425     |
10R-4761     | B310655269BD     |
10R-4761     | B3106673332B     |
10R-4761     | B3106674514D     |
10R-4763     | B310542319C6     |
Solution
If an injector identified in Table 1 is found in an engine, replace the injector with another Reman injector. Contact Reman Product Support at "Runge_Mark_H@Cat.com" and provide both the part number and serial number of the injector located. Hold the mislabeled injectors for a Send injector Back request which will be issued by Mark Runge.
Caterpillar Information System:
320D3 and 323D3 Excavators Machine System Specifications Cab Window
330D2 Excavators Machine System Specifications Cab
2015/09/02 Instructions for Preventing Utilization Messages Being Reported with Duplicate Time Stamps from PL321VSR Satellite Devices {7601}
2015/08/28 New Software Is Available for Certain G3516B Petroleum Engines {1920, 7620}
2015/09/04 A New Installation Procedure Is Used for Certain 3512E Well Frac Engines {1274}
C1.7 and C2.2 Industrial Engines Electrical System
C7.1 Marine Engine Cooling System - Test
C7.1 Commercial Marine Engine Cooling System - Inspect
C7.1 Commercial Marine Engine Cooling System - Check
797 Off-Highway Truck Wheel, Brake and Suspension (Front) - Install - Special Nut Assembly
CN1566, CN2086, CN2586, CN3086, CN3586, CN4086 and CN5086 Electric Motors Maintenance Interval Schedule
C7.1 Commercial Marine Engine Engine Valve Lash - Inspect
797F Off-Highway Truck Field Assembly Walkway - Install
EMCP 4.4 Supervisory Control Panel Control Panel - Inspect/Test
EMCP 4.4 Supervisory Control Panel Fire Prevention and Explosion Prevention
EMCP 4.4 Supervisory Control Panel Safety Messages
EMCP 4.4 Supervisory Control Panel Electrical System
EMCP 4.4 Supervisory Control Panel Model View Illustrations
EMCP 4.4 Supervisory Control Panel Plate Locations and Film Locations
EMCP 4.4 Supervisory Control Panel Control Panel
G3600 A4 Engines Maintenance Interval Schedule - G3600 Wellhead or Natural Gas Engines with a 7.6 :1 Compression Ratio
C7.1 Commercial Marine Engine Flywheel Housing - Inspect
Sub-Base Tank Water Retention Rework for Certain C15, C18, and C9 Generator Sets{1273} Sub-Base Tank Water Retention Rework for Certain C15, C18, and C9 Generator Sets{1273}
C7.1 Commercial Marine Engine Gear Group - Inspect