Electrical System
充电器正在工作时，切勿从蓄电池上断开任何充电器电路或蓄电池电路电缆。 否则，由某些蓄电池产生的易燃气体可能被火花点燃。
为便于防止因点燃某些蓄电池产生的可燃气体而生成的火花，负极 "−" 电缆应该最后从外接电源连接到主接地位置。
每天检查电线有无松动或擦破。 在发动机起动之前，拧紧所有松动的电气连接。 发动机起动之前，要修理好所有擦破的电线。 请参阅操作和保养手册以了解具体的起动说明。
Show/hide table
| |
| 图 1 | g03881462 |
|
典型示例 接地至蓄电池 | |
Show/hide table
| |
| 图 2 | g03881463 |
|
典型示例 备用蓄电池接地 | |
为获得发动机的最佳性能和可靠性，必要将发动机电气系统正确接地。 接地不当会造成电路失控和不可靠。
失控的电路会对曲轴的轴承轴颈表面和铝质部件造成损坏。
未安装发动机至机架接地带的发动机可能因电气放电而损坏。
为确保发动机和发动机电气系统工作正常，必须使用与蓄电池直接相连的发动机到机架的接地带。 这种直接相连可通过将发动机接地线直接连接到机架实现。
接地连接应当紧凑、无腐蚀。 发动机交流发电机必须通过一根足以承受其满载充电电流的导线接地到蓄电池的负极 "-" 端子。
发动机的电源连接和接地连接都应从蓄电池的隔离器引出。
Caterpillar Information System:
C7.1 Marine Engine Cooling System - Test
C7.1 Commercial Marine Engine Cooling System - Inspect
C7.1 Commercial Marine Engine Cooling System - Check
797 Off-Highway Truck Wheel, Brake and Suspension (Front) - Install - Special Nut Assembly
CN1566, CN2086, CN2586, CN3086, CN3586, CN4086 and CN5086 Electric Motors Maintenance Interval Schedule
C7.1 Commercial Marine Engine Engine Valve Lash - Inspect
C7.1 Commercial Marine Engine Fuel System - Prime
2015/09/11 A New Alternator Is Now Used On Certain 3412, C27, and C32 Generator Set Engines {1405}
PM620, PM622, PM820, PM822 and PM825 Cold Planers Electronic System Diagnostic Trouble Codes
3516E Generator Set Engine Sensor Signal (Analog, Passive) - Test
3516B Generator Set Engines with Dynamic Gas Blending Sensor Signal (PWM) - Test
3516E Generator Set Engine Speed/Timing - Test
2015/09/04 A New Installation Procedure Is Used for Certain 3512E Well Frac Engines {1274}
2015/08/28 New Software Is Available for Certain G3516B Petroleum Engines {1920, 7620}
2015/09/02 Instructions for Preventing Utilization Messages Being Reported with Duplicate Time Stamps from PL321VSR Satellite Devices {7601}
330D2 Excavators Machine System Specifications Cab
320D3 and 323D3 Excavators Machine System Specifications Cab Window
Some Reman Injectors Have Been Labeled With The Incorrect Part Number{1254, 1290} Some Reman Injectors Have Been Labeled With The Incorrect Part Number{1254, 1290}
797F Off-Highway Truck Field Assembly Walkway - Install
EMCP 4.4 Supervisory Control Panel Control Panel - Inspect/Test
EMCP 4.4 Supervisory Control Panel Fire Prevention and Explosion Prevention
EMCP 4.4 Supervisory Control Panel Safety Messages
EMCP 4.4 Supervisory Control Panel Electrical System
EMCP 4.4 Supervisory Control Panel Model View Illustrations