Housing (Front) - Install
安装步骤
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
- 将密封垫和前壳体 (5) 在发动机上放置到位。 安装将前壳体固定到发动机上的螺栓 (4) 和螺栓 (9) 。 拧紧有 (X) 标记的螺栓至扭矩为 23 ± 4 N·m (205 ± 35 lb in)。
Show/hide table
图 1 | g01952845 |
- 修整飞轮壳体密封垫,使密封垫与缸体底部轮廓平齐。
- 安装适配器 (8) 、挡圈 (7) 和螺栓 (6) 。
- 安装密封垫、盖 (1) 、螺栓 (3) 和螺栓 (2) 。
Show/hide table
图 2 | g01952803 |
End By:
- 安装前发动机支架。
- 安装曲轴前油封。
- 拆下发动机转速传感器。
- 安装附件驱动。
- 安装水泵。
Caterpillar Information System:
G3304B and G3306B Engines Housing (Front) - Remove
C7.1 Industrial Engine and Generator Set Multiposition Switch Setup
797F and 797F XQ Off-Highway Truck Steering System Bypass Switch (Hydraulic Fan, Steering Oil Filter)
797F and 797F XQ Off-Highway Truck Braking System Gear Motor (Rear Axle Lubrication)
C13, C15, and C18 Tier 4 Final Engines Valve Mechanism
793F Off-Highway Truck Engine Supplement Water Pump (Engine) - Remove and Install
C9.3 Engines for Caterpillar Built Machines Fuel Injection Pump - Remove and Install
C13 Tier 4 Final Engines Rocker Shaft
C15 and C18 Industrial Engines Camshaft Gear - Remove and Install
G3304B and G3306B Engines Crankshaft Rear Seal and Wear Sleeve - Install
G3304B and G3306B Engines Crankshaft Rear Seal and Wear Sleeve - Remove
C7.1 Industrial Engine and Generator Set Throttle Setup
Damaged Liner Seals on 3400 Reman Cylinder Packs {1201, 1216, 1239} Damaged Liner Seals on 3400 Reman Cylinder Packs {1201, 1216, 1239}
C9.3 Engines for Caterpillar Built Machines Engine Oil Cooler - Remove and Install
14L Motor Grader Water Pump - Remove and Install
G3304B and G3306B Engines Gear Group (Front) - Remove
C7.1 Industrial Engine and Generator Set Mode Switch Setup
797F and 797F XQ Off-Highway Truck Power Train Planetary Case and Parts Group - Front Module
G3304B and G3306B Engines Gear Group (Front) - Install
C9.3 Engines for Caterpillar Built Machines Soot Antenna - Remove and Install
G3304B and G3306B Engines Valve Mechanism Cover - Remove and Install
C15 and C18 Engines for Caterpillar Built Machines Flywheel - Remove and Install
793F AC Off-Highway Truck Hydraulic and Braking System Relief Valve (Main)
793F AC Off-Highway Truck Hydraulic and Braking System Solenoid Valve (Brake Pump Unloader)