Flywheel - Remove and Install
Show/hide table
所需工具 | |||
---|---|---|---|
工具 | 零件号 | 零件描述 | 数量 |
A | 138-7573 | 提升支架 | 2 |
B | FT2712 | 导向双头螺栓 | 2 |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
- 将工具 (A) 安装到飞轮上。 使用适当的提升装置。 飞轮的重量约为
40 kg (88 lb) 。 - 拆下两个螺栓 (1)。 安装工具 (B)。
- 卸下将飞轮固定在曲轴上的其余螺栓 (1)。 拆下飞轮 (2)。
Show/hide table
图 2 g01953204 - 必要时,利用手锤和冲头将齿圈 (3) 从飞轮上拆下。
Show/hide table
图 1 | g01953202 |
- 按与拆卸相反的顺序安装飞轮 (2)。
- 拧紧螺栓 (1) 至扭矩为
270 ± 40 N·m (200 ± 30 lb ft) 。
Caterpillar Information System:
G3304B and G3306B Engines Valve Mechanism Cover - Remove and Install
C9.3 Engines for Caterpillar Built Machines Soot Antenna - Remove and Install
G3304B and G3306B Engines Gear Group (Front) - Install
797F and 797F XQ Off-Highway Truck Power Train Planetary Case and Parts Group - Front Module
C7.1 Industrial Engine and Generator Set Mode Switch Setup
G3304B and G3306B Engines Gear Group (Front) - Remove
14L Motor Grader Water Pump - Remove and Install
C9.3 Engines for Caterpillar Built Machines Engine Oil Cooler - Remove and Install
Damaged Liner Seals on 3400 Reman Cylinder Packs {1201, 1216, 1239} Damaged Liner Seals on 3400 Reman Cylinder Packs {1201, 1216, 1239}
G3304B and G3306B Engines Housing (Front) - Install
G3304B and G3306B Engines Housing (Front) - Remove
C7.1 Industrial Engine and Generator Set Multiposition Switch Setup
793F AC Off-Highway Truck Hydraulic and Braking System Relief Valve (Main)
793F AC Off-Highway Truck Hydraulic and Braking System Solenoid Valve (Brake Pump Unloader)
797F and 797F XQ Off-Highway Truck Braking System Slack Adjuster (Front Brakes)
Calculations for Required Inlet Pressure and Back Pressure of the Fuel on C175 Engines that are Utilizing a Day Tank or Standby Application{1250} Calculations for Required Inlet Pressure and Back Pressure of the Fuel on C175 Engines that are Utilizing a Day Tank or Standby Application{1250}
2010/01/18 New O-Ring Seals Are Used on the Front Housings of 3500 Engines {1151, 1162, 1166, 1206, 1207}
G3304B and G3306B Engines Rocker Shaft and Push Rod - Remove
793F and 793F CMD Off-Highway Truck Braking System Slack Adjuster (Rear Brakes)
G3304B and G3306B Engines Rocker Shaft and Push Rod - Install
793F AC Off-Highway Truck Hydraulic and Braking System Check Valve (Service Brake Accumulator)
793F AC Off-Highway Truck Hydraulic and Braking System Check Valve (Parking Brake Accumulator)
C13, C15, and C18 Tier 4 Interim Engines ARD Temperature Is Low
793F AC Off-Highway Truck Hydraulic and Braking System Check Valve (Parking Brake Release)