Engine Oil Coolers - Disassemble
开始:
- 拆卸发动机机油冷却器。 请参阅拆解和组装, "发动机机油冷却器 - 拆卸"。
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
- 从发动机机油冷却器两端拆下以下部件:弯管 (1), 管 (8) 和 底盖 (2)。
- 将适当的起吊设备连接到发动机机油冷却器芯 (4) 上。 发动机机油冷却器芯 (4) 的重量约为
45 kg (100 lb) 。 拆下将发动机机油冷却器芯固定到歧管 (6)和其它歧管 (10)的螺栓。 卸下发动机机油冷却器芯 (4)。 - 从歧管 (6) 上卸下弯管 (7)。 将歧管 (6)和其它歧管 (10)从发动机机油冷却器芯上拆下。
- 将管 (5)和法兰 (3)从油温调节器壳体两侧拆下。
- 将油温调节器壳体 (13)从支架 (11)上拆下。
- 拆下支架 (11)。
- 将底盖 (9)和密封垫从发动机机油冷却器芯 (14)上拆下。
- 将适当的起吊设备连接到发动机机油冷却器芯 (14) 上。 发动机机油冷却器芯 (14) 的重量约为
90 kg (200 lb) 。 将发动机机油冷却器芯从支架组件 (12)上拆下。
Show/hide table
图 1 | g01292777 |
注: 新的油温调节器壳体具有更长的出口。
Caterpillar Information System:
3406E and 3456 Engines for Caterpillar Built Machines Engine Valve Lash - Inspect/Adjust
C15 and C18 Petroleum Generator Sets Engine Operation with Active Diagnostic Codes
3612 and 3616 Engines Engine Oil Coolers - Install
3406E and 3456 Engines for Caterpillar Built Machines Aftercooler - Test
3612 and 3616 Engines Engine Oil Coolers - Remove
C15 Petroleum Generator Set Engines Finding Top Center Position for No. 1 Piston
G3612 and G3616 Engines Engine Oil Pump - Assemble
G3612 and G3616 Engines Engine Oil Pump - Disassemble
3612 and 3616 Engines Engine Oil Pump - Install
C15 Petroleum Generator Set Engines Gear Group (Front) - Time
C27 and C32 Engines Electronic Unit Injector - Test
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks Engine Overspeeds on Start-up
3114, 3116 and 3126 Engines Fuel Quality
G3612 and G3616 Engines Engine Oil Coolers - Assemble
G3612 and G3616 Engines Engine Oil Coolers - Remove
G3612 and G3616 Engines Engine Oil Coolers - Install
C15 Petroleum Generator Set Engines Cooling System - Test
3126B Truck Engine Engine Oil Pan
SR500 Generators Generator Start-up Checklist
G3612 and G3616 Engines Engine Oil Filter Housings - Remove
3406E and 3456 Engines for Caterpillar Built Machines Water Pump - Test
3612 and 3616 Engines Aftercooler - Remove - Standard Aftercooler
Generator Set Load Sensor Engine Will Not Operate in Parallel - Troubleshoot
3408E and 3412E Engines for Caterpillar Built Machines Connecting Rod Bearings - Inspect