Engine Oil Coolers - Remove
- 从冷却系统将冷却液排入合适的容器以便保存或废弃这些冷却液。 请参阅操作和保养手册, "冷却系统冷却液(ELC)- 更换"。
- 从发动机机油冷却器将机油排入适当的容器以便保存或处理。 请参阅操作和保养手册, "发动机机油 - 更换"。
- 将发动机油温传感器的线束组件从发动机机油冷却器上断开。
Show/hide table
图 1 g00608527 - 拆下管组件 (1)。
- 拆下管组件 (4)。
- 拆卸管 (2) 和 (3)。
Show/hide table
图 2 g01292754 - 如果配备,拆下将卡箍 (7)固定到机油冷却器底盖或机油滤清器的螺栓。 将卡箍移离发动机机油冷却器。
- 拆下弯头 (9)。 拆下管 (5)。
- 拆下管 (8)。
- 将管 (10)从机油冷却器底盖上断开。 将 O 形密封圈从法兰上拆下。
注: 在拆卸部件前,电气连接和型号中的其它变型可能需要额外的拆卸或断开。
- 将适当的起吊设备连接在发动机机油冷却器 (6) 上。 发动机机油冷却器 (6) 的重量约为
263 kg (580 lb) 。 拆下将发动机机油冷却器 (6)固定到发动机机油滤清器的螺栓。 拆下发动机机油冷却器 (6)。
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
Show/hide table
注意 |
---|
在检查、保养、测试、调整及维修产品时,请小心确保盛接油液。 在打开任何舱室或拆卸任何含有油液的部件前,请准备好盛接液体用的适当容器。 |
Caterpillar Information System:
C15 Petroleum Generator Set Engines Finding Top Center Position for No. 1 Piston
G3612 and G3616 Engines Engine Oil Pump - Assemble
G3612 and G3616 Engines Engine Oil Pump - Disassemble
3612 and 3616 Engines Engine Oil Pump - Install
C15 Petroleum Generator Set Engines Gear Group (Front) - Time
C27 and C32 Engines Electronic Unit Injector - Test
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks Engine Overspeeds on Start-up
C15 and C18 Petroleum Generator Sets Diagnostic Lamp
3408E and 3412E Engines for Caterpillar Built Machines Fuel System Pressure - Test
Generator Set Load Sensor Engine Does Not Share Load - Troubleshoot
3500B Locomotive Engines Start/Run/Stop Switch
3176B Marine Engine Cold Weather Starting
3406E and 3456 Engines for Caterpillar Built Machines Aftercooler - Test
3612 and 3616 Engines Engine Oil Coolers - Install
C15 and C18 Petroleum Generator Sets Engine Operation with Active Diagnostic Codes
3406E and 3456 Engines for Caterpillar Built Machines Engine Valve Lash - Inspect/Adjust
3612 and 3616 Engines Engine Oil Coolers - Disassemble
3114, 3116 and 3126 Engines Fuel Quality
G3612 and G3616 Engines Engine Oil Coolers - Assemble
G3612 and G3616 Engines Engine Oil Coolers - Remove
G3612 and G3616 Engines Engine Oil Coolers - Install
C15 Petroleum Generator Set Engines Cooling System - Test
3126B Truck Engine Engine Oil Pan
SR500 Generators Generator Start-up Checklist