Engine Oil Pump - Install
Show/hide table
所需工具 | |||
---|---|---|---|
工具 | 零件号 | 零件描述 | 数量 |
A | 138-7573 | 连杆支架 | 1 |
C | - | 导向螺栓 1/2 - 13 UNC × 5 in |
2 |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
- 将 O 形密封圈安装到前壳体和发动机油泵上。 在 O 形密封圈上涂抹清洁的发动机机油。
- 将工具 (C) 安装到前壳体中。
- 将适当的起吊设备连接在发动机油泵 (4) 上。 发动机机油泵 (4) 的重量约为
104 kg (230 lb) 。 - 将发动机油泵上的齿轮与前壳体中的齿轮对齐。 将发动机油泵 (4)安装到工具 (C)上。
- 安装将发动机油泵固定入位的螺栓。
注: 用发动机油稍稍润滑法兰孔。
- 安装法兰 (2)。 将隔套 (1)放入位。 安装将法兰 (2)和隔套 (1)固定到发动机油泵 (4)上的螺栓。
Show/hide table
注意 在运转泵前,机油泵必须带有一个通往轴承的外部供油装置。 用机油润滑泵。 必须能用手使泵自由转动。
- 用干净的发动机油加注发动机油泵。
- 将一个新的 O 形密封圈安装到三通管 (3)中,并安装将三通管 (3)固定到发动机油泵 (4)的螺栓。
Show/hide table
图 1 | g01303921 |
Caterpillar Information System:
C15 Petroleum Generator Set Engines Gear Group (Front) - Time
C27 and C32 Engines Electronic Unit Injector - Test
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks Engine Overspeeds on Start-up
C15 and C18 Petroleum Generator Sets Diagnostic Lamp
3408E and 3412E Engines for Caterpillar Built Machines Fuel System Pressure - Test
Generator Set Load Sensor Engine Does Not Share Load - Troubleshoot
3500B Locomotive Engines Start/Run/Stop Switch
3176B Marine Engine Cold Weather Starting
3114, 3116 and 3126 Engines Fuel Transfer Pump
3034 Engine for Caterpillar Built Machines Engine Oil Pressure
3500B Locomotive Engines Injector Solenoids
3406E and 3456 Engines for Caterpillar Built Machines Fuel System - Prime
G3612 and G3616 Engines Engine Oil Pump - Disassemble
G3612 and G3616 Engines Engine Oil Pump - Assemble
C15 Petroleum Generator Set Engines Finding Top Center Position for No. 1 Piston
3612 and 3616 Engines Engine Oil Coolers - Remove
3406E and 3456 Engines for Caterpillar Built Machines Aftercooler - Test
3612 and 3616 Engines Engine Oil Coolers - Install
C15 and C18 Petroleum Generator Sets Engine Operation with Active Diagnostic Codes
3406E and 3456 Engines for Caterpillar Built Machines Engine Valve Lash - Inspect/Adjust
3612 and 3616 Engines Engine Oil Coolers - Disassemble
3114, 3116 and 3126 Engines Fuel Quality
G3612 and G3616 Engines Engine Oil Coolers - Assemble
G3612 and G3616 Engines Engine Oil Coolers - Remove