Hydraulic System Oil Filter - Replace
請每 1000 小時工時或 1 年更換一次液壓系統機油濾清器。 若已執行 S O S 分析,則可以每 2,000 工時或 2 年更換一次液壓系統機油濾清器。
Show/hide table
注意事項 |
---|
注意液壓機油的清潔度。 保持液壓機油的清潔,以便延長組件壽命,確保發揮最大性能。 |
- 濾清器位於機器右側。
- 為了接住溢出的機油,請在濾清器下方放置合適的容器。 請參閱操作及保養手冊, "一般危險資訊",瞭解液體溢出的相關資訊。
- 取下濾清器外殼底部的塞子,以便預先排空濾清器外殼。
- 用 1.25" 的套管或盒端扳手拆下濾清器外殼。 請勿使用氣動扳手、開口扳手或活動扳手。
- 從濾清器外殼上拆下濾清器濾芯,並以適當的方式棄置濾清器。
- 清潔濾清器外殼。 在濾清器外殼底部安裝塞子。
- 在新的墊圈上塗抹乾淨的機油。
- 在濾清器外殼中安裝新的濾清器濾芯和墊圈。
- 安裝濾清器外殼。 將濾清器外殼鎖緊至
40 ± 5 N·m (30 ± 4 lb ft) 的扭矩。Show/hide table插圖 2 g06133601 - 觀察窺鏡中的液壓油油位。 將油位保持在窺鏡內部。 當機油處於環境溫度下時,應該可以從窺鏡底部看到機油。
請參閱操作保養手冊, "容量(再加注)"。 請參閱操作及維護手冊, "潤滑劑黏度"。
Show/hide table
插圖 1 | g06133607 |
Caterpillar Information System:
PM310, PM312, and PM313 Cold Planer Hydraulic System Oil - Change
PM310, PM312, and PM313 Cold Planer Fuel Tank Water and Sediment - Drain
2570D and 2670D Wheel Feller Buncher Engine Supplement Engine Oil Cooler - Remove and Install
PM310, PM312, and PM313 Cold Planer Engine Oil and Filter - Change
PM310, PM312, and PM313 Cold Planer Engine Oil Sample - Obtain
PM310, PM312, and PM313 Cold Planer Engine Oil Level - Check
PM310, PM312, and PM313 Cold Planer Engine Mounts - Inspect
PM310, PM312, and PM313 Cold Planer Engine Air Filter Primary Element - Clean/Replace
PM310, PM312, and PM313 Cold Planer Diesel Exhaust Fluid Filter - Replace
988K, 990K, 992K and 994K Wheel Loaders Cat® Production Measurement Application / VIMSTM Network Manager Simple Calibration
PM310, PM312, and PM313 Cold Planer Diesel Exhaust Fluid - Fill
PM310, PM312, and PM313 Cold Planer Cooling System Coolant Sample (Level 2) - Obtain
PM310, PM312, and PM313 Cold Planer Hydraulic System Oil Level - Check
PM310, PM312, and PM313 Cold Planer Hydraulic System Oil Sample - Obtain
PM310, PM312, and PM313 Cold Planer Legs (Struts) - Lubricate
785G Off-Highway Truck Systems Electronic Control Module (ECM) - Replace
Medium L and M Series Wheel Loaders Cat Production Measurement Application on Machines Equipped with Product Link: PLE631 or PLE641 Editing Truck and Material Lists
M0077220 (NEHS1231) 115V & 230V Battery Chargers {1401, 751B} M0077220 (NEHS1231) 115V & 230V Battery Chargers {1401, 751B}
797F and 797F XQ Off-Highway Trucks Magnetic Plug (Pump Drive, Hydraulic) - Check
R1700 Load Haul Dump Power Train, Steering, Braking, Hydraulic, and Machine Systems Ride Control Accumulator - Test and Charge
994K Wheel Loader Machine Systems Lift Cylinder - Remove and Install
725C2 and 730C2 Articulated Truck Machine System Center Suspension Frame - Remove and Install
2570D and 2670D Wheel Feller Buncher Engine Supplement Engine - Remove and Install
C175–16 Locomotive Engine Air in Fuel - Test