Hydraulic System Oil - Change
標準的 Cat HYDO Advanced 10 機油更換週期為每 3,000 工時或 18 個月。
液壓油(更換)可採用 6,000 工時或 3 年保養週期。 延長週期必須進行液壓油脂 S.O.S 監測。 S.O.S 監測週期為每 500 小時。 液壓油濾清器的保養週期未改變。
Show/hide table
注意事項 |
---|
注意液壓油的清潔度。 保持液壓油的清潔,以便延長組件壽命,確保發揮最大性能。 |
- 取下液壓油箱蓋。
- 使用乾淨、不易燃的溶劑清洗液壓油箱蓋。
Show/hide table
插圖 2 g06134597 - 排放閥位於液壓油箱底部。 將排放軟管接上排放閥。 打開排放閥,將油液排放到合適的容器內。
附註以適當的方式棄置使用後的機油。 請參閱操作保養手冊, "一般危險事項",瞭解與盛裝溢放的液體相關的資訊。
- 關閉排放閥。
- 重新將乾淨、已過濾的液壓機油加入液壓油箱。 請參閱操作及保養手冊, "容量 (加注) 和潤滑劑黏度"。
- 自油箱頂部的加注口添加機油。
Show/hide table
插圖 3 g06133601 - 觀察窺鏡中的液壓油油位。 將油位保持在窺鏡內部。 當機油處於環境溫度下時,應該可以從窺鏡底部看到機油。
Show/hide table
插圖 1 | g06134594 |
Caterpillar Information System:
PM310, PM312, and PM313 Cold Planer Fuel Tank Water and Sediment - Drain
2570D and 2670D Wheel Feller Buncher Engine Supplement Engine Oil Cooler - Remove and Install
PM310, PM312, and PM313 Cold Planer Engine Oil and Filter - Change
PM310, PM312, and PM313 Cold Planer Engine Oil Sample - Obtain
PM310, PM312, and PM313 Cold Planer Engine Oil Level - Check
PM310, PM312, and PM313 Cold Planer Engine Mounts - Inspect
PM310, PM312, and PM313 Cold Planer Engine Air Filter Primary Element - Clean/Replace
PM310, PM312, and PM313 Cold Planer Diesel Exhaust Fluid Filter - Replace
988K, 990K, 992K and 994K Wheel Loaders Cat® Production Measurement Application / VIMSTM Network Manager Simple Calibration
PM310, PM312, and PM313 Cold Planer Diesel Exhaust Fluid - Fill
PM310, PM312, and PM313 Cold Planer Cooling System Coolant Sample (Level 2) - Obtain
PM310, PM312, and PM313 Cold Planer Coolant Sample (Level 1) - Obtain
PM310, PM312, and PM313 Cold Planer Hydraulic System Oil Filter - Replace
PM310, PM312, and PM313 Cold Planer Hydraulic System Oil Level - Check
PM310, PM312, and PM313 Cold Planer Hydraulic System Oil Sample - Obtain
PM310, PM312, and PM313 Cold Planer Legs (Struts) - Lubricate
785G Off-Highway Truck Systems Electronic Control Module (ECM) - Replace
Medium L and M Series Wheel Loaders Cat Production Measurement Application on Machines Equipped with Product Link: PLE631 or PLE641 Editing Truck and Material Lists
M0077220 (NEHS1231) 115V & 230V Battery Chargers {1401, 751B} M0077220 (NEHS1231) 115V & 230V Battery Chargers {1401, 751B}
797F and 797F XQ Off-Highway Trucks Magnetic Plug (Pump Drive, Hydraulic) - Check
R1700 Load Haul Dump Power Train, Steering, Braking, Hydraulic, and Machine Systems Ride Control Accumulator - Test and Charge
994K Wheel Loader Machine Systems Lift Cylinder - Remove and Install
725C2 and 730C2 Articulated Truck Machine System Center Suspension Frame - Remove and Install
2570D and 2670D Wheel Feller Buncher Engine Supplement Engine - Remove and Install