Starting Below 0°C (32°F)
Show/hide table
NOTICE |
---|
Use ether for cold starting purposes only. After 30 seconds of engine cranking, allow two minutes for the starting motor to cool before cranking again, Turbocharger damage can result, if the engine speed is not kept low until the engine oil pressure is sufficient. |
- Make sure that the transmission is in neutral.
- Move the steering column to the desired position.
- Engage the parking brake.
- Fasten the seat belt.
- Make sure that the control levers are in the HOLD position.
- Turn the engine start switch to the ON position.
- Push the ether starting aid switch inward at two second intervals until the engine starts and the engine runs smoothly.
Show/hide table
Illustration 1 | g00038645 |
- Release the engine start switch key when the engine starts.
For starting below -18°C (0°F), the use of one of the following cold weather starting aids is recommended:
- Coolant heater
- Fuel heater
- Jacket water heater
- Extra battery capacity
Reference: At temperatures below -23°C (-10°F), consult your Caterpillar dealer for additional information or refer to Operation and Maintenance Manual, SEBU5898, "Cold Weather Recommendations".
Caterpillar Information System:
416C, 426C, 428C, 436C and 438C Backhoe Loaders Seat Belt - Inspect
834B and 836 Landfill Compactor Transmission Oil Filter - Replace
834B and 836 Landfill Compactor Rollover Protective Structure (ROPS) - Inspect
834B and 836 Landfill Compactor Transmission Oil - Change
836G Landfill Compactor and 834G Wheel Dozer Lift Cylinder Lower Swivel Bearing - Lubricate
834B and 836 Landfill Compactor Indicators and Gauges - Test
D6R Track-Type Tractor Engine Starting
834B and 836 Landfill Compactor Hydraulic System Oil Level - Check
834B and 836 Landfill Compactor Radiator Grill - Clean
631E Series II Wheel Tractor-Scrapers Before Starting Engine
834B and 836 Landfill Compactor Seat Suspension - Lubricate
834B and 836 Landfill Compactor Hydraulic System Oil Filter (Tank Filter) - Replace
834B and 836 Landfill Compactor Transmission Oil Level - Check
834B and 836 Landfill Compactor Window Wiper - Inspect/Replace
938G Wheel Loader and IT38G Integrated Toolcarrier Windows - Clean
834B and 836 Landfill Compactor Window Washer Reservoir - Fill
CP-433C, CS-431C and CS-433C Paving Compactors Engine Starting with Jump Start Cables
834B and 836 Landfill Compactor After Starting Engine
834B and 836 Landfill Compactor Parking Brake
844 Wheel Dozer Bulldozing
844 Wheel Dozer Ditching
844 Wheel Dozer Side Hill Cut
844 Wheel Dozer Tree or Brush Removal
834B and 836 Landfill Compactor Landfill Compacting