Cowling (Radiator) - Install
安装步骤
Show/hide table
所需工具     | |||
---|---|---|---|
工具     | 零件号     | 零件名称     | 数量     |
A     | 138-7573     | 连接支架     | 2     |
- 安装前,先确认所有零部件均清洁且无异物。 检查所有零部件和 O 形密封圈有无磨损,如有必要,请更换这些零部件和 O 形密封圈。
- 安装前,将 1U-6396 O 形密封圈装配膏 涂在所有 O 形密封圈上。
- 如图所示,将工具 (A) 固定到散热器罩组件 (12) 上。 再将适当的吊具系缚到工具 (A) 上。 将吊具固定到起重装置上。 将散热器罩组件 (12) 安放在机架组件上。
Show/hide table
图 1 | g00557513 |
- 安装将散热器罩组件 (12) 固定在机架组件上的七只螺栓 (37) 。 对散热器罩组件 (12) 的另一侧重复此步骤。
Show/hide table
图 2 | g00569041 |
- 安装将护罩 (30) 固定在机架组件上的五只螺栓 (31) 和垫圈。
Show/hide table
图 3 | g00571184 |
- 在电气连接处连接导线线束 (33) 。 安装将线夹固定在机架组件上的螺栓 (32) 和垫圈。 安装将板组件 (34) 固定在机架组件上的两只螺栓 (35) 和垫圈。 使用新的扎带 (36) 将导线线束 (33) 固定在护罩 (30) 上。
- 在电气连接处连接导线线束 (29) 。
Show/hide table
图 4 | g00557509 |
- 如图所示,将隔板组件 (28) 和导线线束 (25) 安放到机架组件上。 安装将隔板组件 (28) 固定在机架组件上的六只螺栓 (27) 和垫圈。
Show/hide table
图 5 | g00557508 |
- 安装将导线线束 (25) 固定在机架组件上的两只螺栓 (26) 和线夹。
Show/hide table
图 6 | g00557505 |
- 在两处电气连接处连接导线线束 (25) 。
Show/hide table
图 7 | g00557504 |
- 安装将三个缆线组件 (24) 固定在蓄电池断路开关 (22) 上的两个螺母 (23) 和锁紧垫圈。 以 8 ± 2 牛米 (71 ± 18 磅英寸)的扭矩拧紧这两个螺母 (24) 。
Show/hide table
图 8 | g00557490 |
Show/hide table
图 9 | g00557488 |
- 安装将拨动开关 (20) 固定在盖组件 (19) 上的螺母 (21) 。
- 安装将盖组件 (19) 固定在散热器罩组件 (12) 上的六只螺栓 (18) 和垫圈。
Show/hide table
图 10 | g00557422 |
- 将工具 (A) 固定到发动机罩 (2) 上。 如图所示,将适当的吊具系缚到工具 (A) 上。 将吊具固定到起重装置上。 如图所示,将发动机罩 (2) 安放在散热器罩组件上。 发动机罩 (2) 的重量为 218 千克 (480 磅)。
Show/hide table
图 11 | g00570742 |
- 安装将发动机罩 (2) 固定在右侧平台上的两只螺栓 (17) 、螺母和垫圈。
Show/hide table
图 12 | g00570744 |
- 安装将发动机罩 (2) 固定在机架组件上的两只螺栓 (16) 、螺母和垫圈。
Show/hide table
图 13 | g00570743 |
- 安装将支撑组件 (15) 固定在支架组件 (14) 上的开口销 (13) 和垫圈。
Show/hide table
图 14 | g00570745 |
- 安装将发动机罩 (2) 固定在散热器罩组件 (12) 上的九只螺栓 (11) 和垫圈。
Show/hide table
图 15 | g00570741 |
- 在电气连接处连接导线线束 (10) 。 对另一侧重复此步骤。
Show/hide table
图 16 | g00570739 |
- 安装将管组件 (9) 和方形密封件固定在膨胀箱总成 (3) 上的四只螺栓 (8) 和垫圈。
Show/hide table
图 17 | g00570738 |
- 安装将管组件 (7) 和方形密封件固定在膨胀箱总成 (3) 上的四只螺栓 (6) 和垫圈。
Show/hide table
图 18 | g00570737 |
- 将软管组件 (5) 连接到膨胀箱总成 (3) 上。 在膨胀箱总成 (3) 的另一侧重复此步骤。
Show/hide table
图 19 | g00570736 |
- 如图所示,安放盖 (4) 。 安装将盖 (4) 固定在散热器罩组件 (2) 和膨胀箱总成 (3) 上的三只螺栓 (1) 和垫圈。 在膨胀箱总成 (2) 的另一侧重复此步骤。
Show/hide table
图 20 | g00570735 |
- 向散热器中加注冷却液。 请参考操作和保养手册, "冷却系统冷却液(ELC)- 更换"部分。
- 有关正确的加注容量,请参考操作和保养手册, "润滑剂粘度和加注容量"部分。
End By:
- 安装环境温度传感器。 请参考 拆卸和组装, "(环境空气)温度传感器 - 拆除和安装"部分。
- 拆下卡车车斗固定缆线。 请参考 拆卸和组装, "卡车车斗固定缆线 - 拆除和安装"部分。
- 拆下止轮块。 请参考 拆卸和组装, "止轮块 -拆除和安装"部分。
Caterpillar Information System:
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Fault Codes
3524B and C175 Engines for Off-Highway Truck/Tractors Accessory Drive
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Troubleshooting
Electric Protection System Energize-To-Run For Generator Set, Industrial and Marine Diesel Engines ETR Junction Box-Switchgear Not Required (OP,WT,OS)
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks MID 036 - CID 0248 - FMI 09 Cat Data Link not communicating
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Electrical Test Procedures
24H Motor Grader Braking System Towing
834G Wheel Dozer and 836G Landfill Compactor Power Train General Information
24H Motor Grader Braking System Filters and Screens
Generator Service Literature Index{4450} Generator Service Literature Index{4450}
D350E Series II and D400E Series II Articulated Trucks Steering, Suspension, and Body Hoist Hydraulic Systems Accumulator (Suspension) - Test and Charge
24H Motor Grader Braking System Pressure Switch
D350E Series II and D400E Series II Articulated Trucks Steering, Suspension, and Body Hoist Hydraulic Systems Tailgate Cylinder - Test
797 Off-Highway Truck Engine Supplement Muffler - Remove
Weld Repair Procedure for Field Retrofit of Large Off-Highway Truck Frame Superstructure {7050, 7253} Weld Repair Procedure for Field Retrofit of Large Off-Highway Truck Frame Superstructure {7050, 7253}
Electric Protection System Energize-To-Run For Generator Set, Industrial and Marine Diesel Engines ETR Junction Box-Switchgear Not Required (OP,WT)
797 Off-Highway Truck Steering System Relief Valve (Steering) - Test and Adjust - Backup Relief Valve
554 Forwarder and 574 Forwarder Lubricant Viscosities
Challenger 65C, Challenger 65D, Challenger 65E, Challenger 70C, Challenger 75C, Challenger 75D, Challenger 75E, Challenger 85C, Challenger 85D, Challenger 85E and Challenger 95E Agricultural Tractors Machine Performance Panel Speed Sensor (Engine)
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Machine Systems Steering Control - Remove
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Machine Systems Steering Control - Install
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Machine Systems Hitch (Lift Arm) - Remove and Install
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Machine Systems Hitch (Lift Link) - Remove and Install
3524B and C175 Engines for Off-Highway Truck/Tractors Flywheel