MID 036 - CID 0248 - FMI 09 Cat Data Link not communicating
Conditions Which Generate This Code:
The battery voltage to the Electronic Control Module (ECM) has been above 9 VDC for the last two seconds. The engine is not cranking. Communications with the VIMS and/or the VIDS has not been established for six seconds. Communication was lost for two or more seconds. The CID-FMI is logged in memory.
System Response:
The CID-FMI may be viewed on a display module or Caterpillar Electronic Technician (ET). The features which receive inputs from the Cat Data Link are disabled.
Test Step 1. Perform the following diagnostic procedure: "Cat Data Link"
Results:
- OK - STOP
- REPAIRED, OK - STOP
Caterpillar Information System:
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Electrical Test Procedures
24H Motor Grader Braking System Towing
834G Wheel Dozer and 836G Landfill Compactor Power Train General Information
24H Motor Grader Braking System Filters and Screens
Generator Service Literature Index{4450} Generator Service Literature Index{4450}
D350E Series II and D400E Series II Articulated Trucks Steering, Suspension, and Body Hoist Hydraulic Systems Accumulator (Suspension) - Test and Charge
24H Motor Grader Braking System Pressure Switch
416C, 426C, 428C, 436C and 438C Backhoe Loaders Hydraulic and Steering System Steering Cylinder (2WD)
35, 45 and 55 Challengers Power Train Accumulator - Remove and Install
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Electronic Control Module (ECM) - Replace
793C Off-Highway Truck/Tractor Power Train Lateral Control Rod (Rear Axle Housing) - Install
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Machine Systems Cab - Install
Electric Protection System Energize-To-Run For Generator Set, Industrial and Marine Diesel Engines ETR Junction Box-Switchgear Not Required (OP,WT,OS)
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Troubleshooting
3524B and C175 Engines for Off-Highway Truck/Tractors Accessory Drive
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Fault Codes
789C Off-Highway Truck Engine Supplement Cowling (Radiator) - Install
D350E Series II and D400E Series II Articulated Trucks Steering, Suspension, and Body Hoist Hydraulic Systems Tailgate Cylinder - Test
797 Off-Highway Truck Engine Supplement Muffler - Remove
Weld Repair Procedure for Field Retrofit of Large Off-Highway Truck Frame Superstructure {7050, 7253} Weld Repair Procedure for Field Retrofit of Large Off-Highway Truck Frame Superstructure {7050, 7253}
Electric Protection System Energize-To-Run For Generator Set, Industrial and Marine Diesel Engines ETR Junction Box-Switchgear Not Required (OP,WT)
797 Off-Highway Truck Steering System Relief Valve (Steering) - Test and Adjust - Backup Relief Valve
554 Forwarder and 574 Forwarder Lubricant Viscosities
Challenger 65C, Challenger 65D, Challenger 65E, Challenger 70C, Challenger 75C, Challenger 75D, Challenger 75E, Challenger 85C, Challenger 85D, Challenger 85E and Challenger 95E Agricultural Tractors Machine Performance Panel Speed Sensor (Engine)