Water Pump - Install
Show/hide table
所需工具 | |||
工具 | 零件号 | 零件描述 | 数量 |
A | 1U-6396 | O 形圈组装固定胶 | - |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
Show/hide table
注意 |
---|
由于端面密封损坏,水泵可能会发生泄漏。 轴和壳体之间的相对移动可能会使传动轴接触到水泵上的端面密封。 如果发生接触,将损坏端面密封并导致过早发生故障。 |
- 安装前,请参阅专门说明书 , REHS9244,了解水泵的正确装卸步骤。
Show/hide table
图 1 g01354173 - 将 O 形密封圈装在水泵 (3) 上。 用工具 (A)润滑 O 形密封圈。
- 放好密封垫 (2),然后用适当的起吊设备将水泵 (3) 安装到位。 安装螺栓 (1)。
- 安装螺栓 (6)。
- 用工具 (A)润滑管上的 O 形密封圈。 如有必要,将 O 形密封圈安装到管上。
- 将密封件 (7)和泵进口弯头 (5)安装到水泵 (3)上。 安装螺栓 (4)。
- 加注冷却系统。 请参阅操作和保养手册, "冷却系统冷却液 - 更换"。
Caterpillar Information System:
G3516B and G3520B Generator Set Engines Electric Starting Motor - Remove and Install
C4.4 and C6.6 Engines for Caterpillar Built Machines 5 Volt Sensor Supply Circuit - Test
G3516B and G3520B Generator Set Engines Engine Oil Pan - Install
C9.3 Engines for Caterpillar Built Machines Rocker Arm and Shaft - Install
G3516B and G3520B Generator Set Engines Engine Oil Pan - Remove
2007/02/01 Retirement of the Paper Version of Truck Engine News {1000}
CX35 On-Highway Transmission Transmission Planetary - Assemble
C9 On-highway Engine Rocker Arm and Shaft - Remove
C7 and C9 On-Highway Engines Engine Monitoring Lamp Parameters
C9 On-highway Engine Valve Mechanism Cover - Remove and Install
3508C, 3512C and 3516C Marine Engines Water Pump - Remove
2007/02/01 New Improved Air Lines for Air Compressors Are Now Used {5502}
3512B and 3516B High Displacement Locomotive Engines Maintenance Recommendations
C9 On-highway Engine Unit Injector - Install
G3520C and G3520E Engines Valve Mechanism
2007/04/09 A New Fan Pulley Group is Used {1359}
C9 On-highway Engine Unit Injector - Remove
3500C Marine Auxiliary Engines Boost Pressure Is High
C15 and C18 Industrial Engines Flywheel Housing
C4.4 (Mech) Industrial Engine Fuel Tank Water and Sediment - Drain
2007/03/12 Turbochargers {1052}
3500C Marine Auxiliary Engines Fuel Pressure Is Low
3508C, 3512C and 3516C Marine Engines Auxiliary Water Pump - Disassemble
3500C Marine Auxiliary Engines Engine Cranks but Does Not Start