Cooling System Coolant Extender (ELC) - Add
Show/hide table
熱的冷卻液、蒸氣和鹼可能造成人身傷害。 在引擎工作溫度下,引擎冷卻液是熱的且具有壓力。 散熱器和所有通向加熱器或引擎的管路內,都含有熱的冷卻液或蒸氣。 與它們有任何接觸,都可能引擎嚴重的燙傷。 只在引擎停機時,且冷卻系統壓力蓋的溫度已不燙手時,才可以慢慢拔掉冷卻系統壓力蓋來釋放壓力。 冷卻液還很燙時,請勿嘗試旋緊軟管接頭,這樣軟管可能會脫離,造成燙傷。 冷卻系統冷卻液添加物含有鹼。 避免與皮膚及眼睛接觸。 |
Show/hide table
注意事項 |
---|
在檢驗、保養、測試、調整及修理產品時,請小心確保油液有容器盛裝。 在打開任何艙室或拆卸任何含有用液的組件前,應準備好盛裝用液的適當容器。 |
使用 Caterpillar 長效冷卻液 (ELC) 時,必須向冷卻系統加注延長劑。 請參閱操作及保養手冊, "保養週期計劃表",以瞭解適當的維修週期。 延長劑用量由冷卻系統容積決定。
- 停止引擎並讓引擎冷卻。
Show/hide table
插圖 1 g01463648 - 打開蓋子 (1)。
- 清潔冷卻系統壓力蓋周圍區域的灰塵或碎屑。 在取下冷卻系統壓力蓋之前,必須先完成此動作。
- 慢慢地取下冷卻系統壓力蓋,以釋放壓力。
- 將散熱器的部分冷卻液排放到適當的容器中。 如此一來就有空間添加冷卻系統長效冷卻液。
- 若要添加冷卻系統冷卻液延長劑,請參閱特別出版品, SEBU6250, "長效冷卻液 (ELC)"。 請參閱表格,以取得冷卻系統所須添加的 Caterpillar 長效冷卻液 (ELC, Extended Life Coolant) 延長劑的正確劑量。
- 裝上冷卻系統壓力蓋。 關上蓋子。
Caterpillar Information System:
2008/03/03 A New Check Valve for the Spray Bars is Now Used on Utility Compactors {6609}
CD54 Paving Compactor Operation Information
325D Forest Machine Machine System Specifications Boom - Log Loader
2008/07/21 New Radiator Header Tank Hosing is Now Used {1353}
AP-1000D and BG-260D Asphalt Pavers Propel System Final Drive
2008/05/12 An Improved Muffler is Available for Motor Graders {1062, 1062}
2008/03/31 Increased Filtration of the Power Train is Now Available {3067}
2008/04/28 An Improved Refrigerant Compressor Gp Is Available {1802}
2008/03/17 The Procedure to Mount the Rear Axle is Updated {3260, 3278, 3282, 4068}
3512C Engine for Caterpillar Built Machines Auxiliary Water Pump - Remove
120K Motor Grader Additional Messages
2008/03/03 Caterpillar Machine Control and Guidance Repair Center {7220, 7604}
120K Motor Grader Cooling System Pressure Cap - Clean/Replace
2008/05/19 A New Version of Caterpillar Electronic Technician (ET) is Now Available {0785, 7600, 7610}
12K, 140K and 160K Motor Graders Air Dryer Desiccant - Replace
795F AC and 795F AC XQ Off-Highway Trucks Battery Disconnect Switch
2008/03/03 A New Throttle Position Sensor is Now Used {1913}
795F AC and 795F AC XQ Off-Highway Trucks Engine Shutdown Switch
MINEGEM Machine Control ; Guidance Products Seat
PS-150B and PS-200B Paving Compactors Maintenance Interval Schedule
966H Wheel Loader and 972H Wheel Loader Power Train MID 081 - CID 0621 - FMI 04
966H Wheel Loader and 972H Wheel Loader Power Train MID 081 - CID 0622 - FMI 03
966H Wheel Loader and 972H Wheel Loader Power Train MID 081 - CID 0622 - FMI 04
12K, 140K and 160K Motor Graders Cooling System Coolant Sample (Level 1) - Obtain