CID 0164 FMI 04 Injector Actuation Pressure voltage low
Conditions Which Generate This Code:
The Electronic Control Module (ECM) detects the following conditions:
- The voltage signal from the injection actuation pressure sensor is below 0.1 VDC for one second.
- The ECM has been powered for at least three seconds.
System Response:
The ECM will log the diagnostic code. The ECM flags injection actuation pressure as invalid data and a default value of 12 MPa (1740 psi) is used.
- Low power
Test Step 1. Perform the following diagnostic procedure: Engine Sensor Open/Short Circuit- Test
Results:
- OK - STOP
Caterpillar Information System:
AP-655C and BG-2255C Asphalt Pavers Machine Systems Control Valve (Hydraulic Generator) - Assemble - AYP1-Up and B9G1-Up
AP-655C and BG-2255C Asphalt Pavers Machine Systems Control Valve (Hydraulic Generator) - Disassemble - AYP1-Up and B9G1-Up
CB-334E and CB-335E Vibratory Compactors Machine Systems Water Spray System Troubleshooting
HF181, HF201, HF202, HF221 and HF222 Felling Heads Felling Head Accumulator Arm - Install - HF221 and HF222
HF181, HF201, HF202, HF221 and HF222 Felling Heads Felling Head Accumulator Arm - Assemble - HF221 and HF222
HF181, HF201, HF202, HF221 and HF222 Felling Heads Felling Head Accumulator Arm - Disassemble - HF221 and HF222
HF181, HF201, HF202, HF221 and HF222 Felling Heads Felling Head Hydraulic Cylinder (Accumulator Arm) - Remove and Install - HF221 and HF222
AP-655C and BG-2255C Asphalt Pavers Machine Systems Control Valve (Hydraulic Generator) - Install - CDG1-Up and CKR1-Up
AP-655C and BG-2255C Asphalt Pavers Machine Systems Control Valve (Hydraulic Generator) - Remove - CDG1-Up and CKR1-Up
C13, C15, and C18 Generator Set Engines Engine Cranks but Will Not Start
PS-150C Pneumatic Compactor Propel System Flow Divider Valve
CB-334E and CB-335E Vibratory Compactors Machine Systems Water Spray Pump Flow - Test
120H and 135H Motor Graders Air System and Brakes Check Valve (Air Tank)
267B, 277B and 287B Multi Terrain Loaders Power Train Piston Pump (Hydrostatic) - Install - 287B Multi Terrain Loader
CB-214E, CB-224E and CB-225E Vibratory Compactors Machine Systems Water Spray Pump Flow - Test
TK370 Wheel Feller Buncher, TK380 Wheel Feller Buncher, TK371 Industrial Tractor and TK381 Industrial Tractor Machine Systems Work Tool Linkage
PS-150C Pneumatic Compactor Machine System Steering Control
CB-334E and CB-335E Vibratory Compactors Machine Systems Hydraulic Cylinder (Steering)
PS-150C Pneumatic Compactor Machine System Oscillating and Steering Bar
AP-655C and BG-2255C Asphalt Pavers Machine Systems Feeder Drive Shaft Group - Remove
AP555E and BG555E Asphalt Pavers Machine Systems Feeder Drive Shaft Group - Disassemble
AP500F Asphalt Paver Machine Systems Feeder Drive Shaft Group - Assemble
AP-655C and BG-2255C Asphalt Pavers Machine Systems Feeder Drive Shaft Group - Install
AP555E and BG555E Asphalt Pavers Machine Systems Plates (Drag Pans) - Remove and Install