Turbocharger - Assemble
组装步骤
Show/hide table
| 注意 |
|---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
Show/hide table
| 注意 |
|---|
压缩机壳体必须在涡轮增压器组件上保持平直不倾斜。 倾斜可能会导致压缩机叶片倾翻或导致压缩机轴损坏。 |
- 将压缩机壳体 (1) 和涡轮壳体 (4) 安置在涡轮增压器管壳 (5) 上。
Show/hide table
 | |
| 图 1 | g01237470 |
- 拧紧 V 形带箍 (2) 上的螺母至扭矩为 14 ± 1 N·m (10 ± 1 lb in)。 用软面锤轻轻敲击卡箍直径周围区域。 拧紧螺母至扭矩为 14 ± 1 N·m (10 ± 1 lb ft)。
注: 确保配合面平整。
- 拧紧 V 形带卡箍 (6) 上的螺母至扭矩为 14 ± 1 N·m (10 ± 1 lb in)。 用软面锤轻轻敲击卡箍直径周围区域。 再次拧紧螺母至扭矩为 14 ± 1 N·m (10 ± 1 lb ft)。
- 确保叶轮可以自由旋转。
- 将软管 (3) 连接到压缩机壳体上。
End By: 安装涡轮增压器。 请参阅 拆解和组装, "涡轮增压器 - 安装"。
Caterpillar Information System:
C15 and C18 Generator Set Engines Turbocharger - Disassemble
Oil Pan and Gasket{1302, 1302} Oil Pan and Gasket{1302, 1302}
2010/09/01 Cylinder Pack Upgrade Is Available for Certain 3406B and 3406C Engines When Replacing All Six Cylinders Packs {1201, 1225}
CX28, CX31 and CX35 On-Highway Transmissions Power Train Electronic Control System Transmission Shifting Function
CX31 On-Highway Transmission Transmission Oil Sample - Obtain
CX31 On-Highway Transmission Transmission Oil Level - Check
CX31 On-Highway Transmission Transmission Oil - Change
CX31 On-Highway Transmission Transmission Warm-up
CX31 On-Highway Transmission Transmission Control
3126B and 3126E Truck Engines Electronic Control Wiring Group
Check Engine Light ON with No Active Fault Codes for 3126E Engines{1901, 1902, 7431, 7620} Check Engine Light ON with No Active Fault Codes for 3126E Engines{1901, 1902, 7431, 7620}
C6.6 Engines for Caterpillar Built Machines Engine Oil Pan
C15 and C18 Generator Set Engines Exhaust Manifold - Remove and Install
C3.3 Industrial Engine Air in Fuel - Test
C3.3 Industrial Engine Fuel Injector - Remove
Procedure for Testing the 167-1709 Pressure Sensor Gp on the 3126 Industrial Engine{1718, 1916, 1917, 1923, 1924, 1925} Procedure for Testing the 167-1709 Pressure Sensor Gp on the 3126 Industrial Engine{1718, 1916, 1917, 1923, 1924, 1925}
3126B and 3126E Truck Engines Air Compressor - Midland Air Compressors
2006/02/13 Enhanced Voltmeter Leads Are Now Available {0785}
G3500 A3 Engines Replacing the ECM
2006/02/01 Troubleshooting Engines with Mechanical Unit Injection (MUI) {1290, 7569}
3126B and 3126E Truck Engines Air Compressor - Midland Air Compressors
C15 and C18 Generator Set Engines Engine Oil Filter Base - Remove
G3500 A3 Engines Symptoms
G3500 A3 Engines Electronic Service Tool Will Not Communicate with ECM