Spark Plugs - Remove and Install
Show/hide table
所需工具 | |||
工具 | 零件号 | 零件描述 | 数量 |
A | 6V-0006 | 钳子 | 1 |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
- 断开电气连接 (1)。
- 拆下三个螺栓 (2)。
- 卸下变压器 (3) 和 O 形密封圈。 检查 O 形密封圈是否磨损或损坏。 如有必要,更换 O 形密封圈。
- 卸下火花塞伸长部(未显示)。
- 卸下火花塞(未显示)。
Show/hide table
图 1 | g00868455 |
Show/hide table
所需工具 | |||
工具 | 零件号 | 零件描述 | 数量 |
A | 6V-0006 | 钳子 | 1 |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
- 安装火花塞(未显示)。 如果火花塞螺纹脏污,清洁火花塞螺纹。 同时清洁缸盖的密封表面。 卸下管组件,以便清洁表面。
- 拧紧火花塞至扭矩
68 ± 4 N·m (50 ± 3 lb ft) 。 火花塞间隙为0.28 ± 0.04 mm (0.011 ± 0.001 inch) 。注: 如果重复使用火花塞,一定要使用新垫片。
- 更换火花塞伸长部(未显示)。
Show/hide table
图 2 g00868455 - 更换变压器 (3) 和垫片。
- 更换三个螺栓 (2)。
- 连接电气连接 (1)。 当您拧紧变压器接头时,使用工具 (A) 顺时针拧紧螺母,直到拧紧螺母。
Caterpillar Information System:
3500 Generator Set Engines Temperature Gauge
2002/03/01 A New Service Manual, RENR5971, "System Operation And Programming Guides For Digital Governor Control Used On 3618 Engine" Is Available {1908}
3500 Generator Set Engines Pressure Gauge - Hydraulic Oil
G3606 and G3608 Engines Fuel Control Valve - Remove and Install
3618 Engine Thermocouple - Test - Main Bearings' Thermocouples
3500 Industrial Engines Vacuum Gauge
3618 Engine Particle Detector - Test
3618 Engine Oil Mist Detector - Test
3618 Engine Oil Pressure Transducer - Test - Shutdown for Low Engine Oil pressure
3500 Generator Set Engines Pressure Gauge - Engine Oil
2002/03/11 Correction to Information Regarding the Need for Timing Calibration after Replacing the Engine ECM {1901, 1912, 1912}
3500 Industrial Engines Differential Pressure Gauge
G3612 and G3616 Engines Detonation Sensor - Remove and Install
3500 Generator Set Engines Temperature Gauge
3618 Engine Transducer - Calibrate
3406E, C12, C15 and C18 Marine Engines Sensors and Electrical Connectors
3406E, C12, C15 and C18 Marine Engines Analog Sensor Supply Circuit - Test
3406E, C12, C15 and C18 Marine Engines Electrical Power Supply Circuit - Test
N3 Series Brushless Alternators Stator - Test
G3612 and G3616 Engines Fuel Lines - Remove and Install
3500 Generator Set Engines Sending Unit - Engine Oil Pressure
3500 Generator Set Engines Sending Unit - Water Temperature
3512B Petroleum Engines with the ADEM 2 Electronic Control Module Electrical Connectors and Functions
3500 Generator Set Engines Service Meter