Turbocharger
Show/hide table
Illustration 1 | g01224675 |
(1) Nut
Apply 4C-5598 Anti-Seize Compound to the studs.
Tighten the nuts to the following torque. ... 54 ± 5 N·m (40 ± 4 lb ft)
(2) Exhaust manifold
Show/hide table
Illustration 2 | g01224676 |
(3) Canister for the wastegate
(4) Compressor
(5) Tighten the clamp to 14.0 ± 1.0 N·m (10 ± 1 lb ft). Tap lightly around the clamp. Tighten the clamp again to 14.0 ± 1.0 N·m (10 ± 1 lb ft).
(6) Turbine
Caterpillar Information System:
3408E and 3412E Engines for Caterpillar Built Machines Cylinder Block - Inspect
3176C and 3196 Engines for Caterpillar Built Machines Main Bearings - Inspect
3114, 3116 and 3126 Industrial, Marine and Generator Set Engines Piston and Rings
Electronic Modular Control Panel II (EMCP II) For MUI Engines Relay (Overvoltage)
3176C and 3196 Engines for Caterpillar Built Machines Connecting Rod Bearings - Inspect
3406E and 3456 Generator Set Engines Turbocharger - Install
3406E and 3456 Generator Set Engines Turbocharger - Remove
3500B Engines Engine Oil Pan
3500B and 3500B High Displacement Generator Set Engines MID 036 - CID 0336 - FMI 02 Incorrect ECS Switch inputs
3500B and 3500B High Displacement Generator Set Engines MID 036 - CID 0289 - FMI 13 Unfiltered Fuel Pressure calibration required
3500B and 3500B High Displacement Generator Set Engines MID 036 - CID 0289 - FMI 03 Unfiltered Fuel Pressure open/short to +batt
3500B and 3500B High Displacement Generator Set Engines MID 036 - CID 0276 - FMI 04 Left Turbo Inlet Pressure short to ground
3126B Marine Engine Aftercooler
3176C and 3196 Engines for Caterpillar Built Machines Cylinder Liner Projection - Inspect
3500B Engines and 3500 Engines with EUI Option Air Shutoff System
Accessing Flash Software for Machines{7610, 7620} Accessing Flash Software for Machines{7610, 7620}
Electronic Modular Control Panel II (EMCP II) For MUI Engines Relay (Overcurrent)
3406E and 3456 Generator Set Engines Flywheel Housing - Remove and Install
3500B and 3500B High Displacement Generator Set Engines Engine Monitoring System
Electronic Modular Control Panel II (EMCP II) For MUI Engines Fault Identification
3126B Marine Engine Auxiliary Water Pump
3306C Engines for Caterpillar Built Machines Flywheel - Inspect
Electronic Modular Control Panel II (EMCP II) For MUI Engines CID 100 FMI 2 Pressure Sensor (Engine Oil) Incorrect Signal - Test
3408E and 3412E Engines for Caterpillar Built Machines Flywheel Housing - Inspect