Potential Corrosion of the Connection to the Antenna on Certain Soil Compactors{7338}
- Soil Compactor:
- CP56 (S/N: C5P1-UP; FCP1-UP)
- CP64 (S/N: P7F1-UP; C6P1-UP)
- CS74 (S/N: C8F1-UP; C8S1-UP)
- CS76 (S/N: JCS1-UP; CYX1-UP)
- CP74 (S/N: P8F1-UP)
- CP76 (S/N: C7L1-UP; JCP1-UP)
- CS56 (S/N: C5S1-UP; FCS1-UP)
- CS64 (S/N: C7F1-UP; C6S1-UP)
- CP64 (S/N: P7F1-UP; C6P1-UP)
Introduction
The problem that is identified below does not have a known permanent solution. Until a permanent solution is known, use the solution that is identified below.
Problem
Corrosion has been found at the connection between the 8E-1118 Antenna As and 117-2932 Coaxial Cable Assembly . This connection is external to the 320-9870 Cab Ar . The presence of corrosion at the connection may cause the radio to be unreliable.
Solution
Show/hide table
Illustration 1 | g01803353 |
Orient antenna (1) to the upright position. Clean connection (2).
Show/hide table
Illustration 2 | g01803373 |
Apply 151-1340 Dielectric Grease to the inside of the coaxial cable assembly and the outside of the coaxial cable assembly.
Caterpillar Information System:
2009/02/02 An Improved Connector is Now Available for the Backhoe Loader with Side Shift (BHL-SS) {7304, 7332}
Reinforcement of the Hydraulic Oil Tank{5056} Reinforcement of the Hydraulic Oil Tank{5056}
Air Conditioner Fittings Leak{1802, 1808} Air Conditioner Fittings Leak{1802, 1808}
584 and 584HD Forwarders Machine Preheater Heater Operation
CB54, CB54 XW and CB64 Vibratory Compactors Propel System Solenoid Valve (Reverse Propel) - Calibrate
CB54, CB54 XW and CB64 Vibratory Compactors Propel System Solenoid Valve (Forward Propel) - Calibrate
584 and 584HD Forwarders Machine Preheater Before Starting the Heater
795F AC and 795F AC XQ Off-Highway Truck Power Train Electronic Control System MID 170 - CID 0168 - FMI 03
795F AC and 795F AC XQ Off-Highway Truck Power Train Electronic Control System MID 169 - CID 0168 - FMI 04
CP44 and CS44 Vibratory Soil Compactors Fuses - Replace
795F AC and 795F AC XQ Off-Highway Truck Power Train Electronic Control System MID 169 - CID 0168 - FMI 03
CP44 and CS44 Vibratory Soil Compactors Fuel Tank Water and Sediment - Drain
420E, 430E, 432E, 434E, 442E and 444E Backhoe Loaders System Pressure Release
2009/02/16 Shims are Now Used in the Torque Converter and Updrive {3101, 3159}
2009/02/02 An Improved Seal is Used {1157, 7555}
2009/02/09 New Parts Update the Water Lines Group {1380}
Procedure to Replace the Transmission Harness on Certain R1700G Load Haul Dumps{1408} Procedure to Replace the Transmission Harness on Certain R1700G Load Haul Dumps{1408}
AccuGrade® Version 11 Compaction GPS Mapping and Measurement System GPS Accuracy Mode
CP44 and CS44 Vibratory Soil Compactors Hydraulic System Oil - Change
AccuGrade® Version 11 Compaction GPS Mapping and Measurement System General Information
AccuGrade® Version 11 Compaction GPS Mapping and Measurement System Modes of Operation
AccuGrade® Version 11 Compaction GPS Mapping and Measurement System Guidance Terms
AccuGrade® Version 11 Compaction GPS Mapping and Measurement System Data Card
Installing the 337-3991 Radio Installation Gp {7338} Installing the 337-3991 Radio Installation Gp {7338}