1983/05/30 Caterpillar


Installation Procedure For Woodward 3161 and UG8 Governors{1264}

Usage:


All 3500 Series Engines

The procedure that follows should be used when a Woodward 3161 or Woodward UG8 Governor is installed on a 3500 Series Engine. Use of this procedure will put the output terminal shaft in the correct alignment with the cover on the accessory drive housing. When the output terminal shaft is not in the correct alignment with the cover, there can be friction between the lip type seal in the cover and the output terminal shaft. This friction can cause the governor to not operate correctly.

Installation Procedure

1. Loosen bolts (1) that hold the governor drive housing in position against the adapter. See Illustration 1.


Illustration 1.

2. Install support (2) on the governor. Do no tighten the bolts. See Illustration 2.

NOTE: A new support is now used that has slots (notches) in it. These supports can be installed between the governor and cover in Step 9.


Illustration 2.

3. Put clean engine oil or glycerine on the bore of the lip type seal in the cover.

4. Make sure two bolts (4) are in position in cover (5) and install the cover on output terminal shaft (7). Install two bolts (3) but do not tighten them at this time.

5. Install lever (6) on the output terminal shaft as shown. Install the bolt and washer that holds the lever in position.

6. Put the governor and cover in position on the engine. Make sure the side of the governor that is nearest to the engine block is parallel to the accessory drive housing. Install and tighten bolts (10). See Illustration 3.


Illustration 3.

7. Move the governor and drive housing as needed until the bolt holes in the cover are in alignment with the bolt holes in the accessory drive housing. Tighten bolts (9).

8. Tighten bolts (8) that hold the cover in position against the accessory drive housing.

9. Tighten bolts (3) and the bolts that hold support (2) in position against the governor.

10. Make sure output terminal shaft (7) turns freely. See Illustration 4. If the output terminal shaft does not move freely, do Steps 6 through 10 again.

NOTE: Spring pressure in the Woodward 3161 Governor should cause the output terminal shaft to go back to the fuel-off position when released from the full-fuel position. Spring pressure in the Woodward UG8 Governor should cause the output terminal shaft to move when released from the full-fuel position but it will not go all the way to the fuel-off position.


Illustration 4.

Caterpillar Information System:

1983/05/23 Anti-Spin Control Available To Improve Traction{4250,4001}
1983/05/23 Use The 6V4930 Battery Load Tester To Test Batteries{0651}
1983/05/23 New Core Assembly Used In Transmission Oil Cooler{1375}
1983/05/16 Reuse Of Engine Bearings{1230}
1983/05/16 Installation Procedure For Seals On Cab Doors{7308}
1983/05/16 Selection Of The Correct Battery For Use With Diagnostic Tools{1401,0650}
1983/05/16 Procedure To Clean Oil Passages In Crankshafts And Cylinder Blocks{0622,0675,1201,1202}
1983/05/16 New Planet Carrier Shafts And Pins For Transmission{3150}
1983/05/16 Use Care During Removal Of The Oil Line Screen For Brake And Torque Converter Oil Cooler{1307,1366,0374}
1983/05/16 New Specification For Clearance Between Fuel Rack Slot And Cross Link{1257}
1983/05/09 New Piston Ring Group Available For Higher Horsepower Applications{1215,1214,1213,1226}
1983/05/09 New Fuel Setting Information{0374,1257,1286}
1983/05/30 New Piston Ring Group Used{1215}
1983/05/30 Special Procedure Needed To Clean 3500 Series Engine Pistons{0374,1214}
1983/05/30 New Rod Ends With Steel Bearings Are Now Used For The Transmission Control Linkage{3156}
1983/05/30 Information Concerning Caterpillar XT Hose{7554,0374}
1983/05/30 Seal And Valve Repair Kit Available To Service Relay Valve{4280}
1983/05/30 New Circle Shoes With Replaceable Wear Strips Used{6154,6155}
1983/05/30 Wellhead And Sour Gas Can Cause Shortened Service Life For Gas Engines{1000,1250}
1983/05/30 Installation Procedure For Bowl, Bucket And Ripper Tips{6805,6808}
1983/05/30 Correct Lubrication Instruction Films Now Used{7557,1300}
1983/06/06 Reference Chart For Service Magazine Articles On Improvements To All 3300 Series Engines{0374}
1983/06/06 Dial Face Changed On 8S2263 Valve Spring Tester{1108}
1983/06/06 Remanufactured Alternators And Starting Motors Are Available{1405,1453}
Back to top
The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.