Turbocharger - Disassemble
Start By:
- Remove turbocharger.
Show/hide table
NOTICE |
---|
Keep all parts clean from contaminants. Contaminants may cause rapid wear and shortened component life. |
Show/hide table
NOTICE |
---|
Do not attempt to disassemble the turbocharger cartridge assembly. The turbocharger cartridge assembly is not field serviced, and should be replaced only as a unit. |
- Position the turbocharger on a bench. Place alignment marks on compressor housing (1), turbocharger cartridge (2), and turbine housing (5).
- Remove bolts (4) and compressor housing (1).
- Loosen clamp assembly (5) and remove turbine housing (3).
Show/hide table
Illustration 1 | g03841646 |
Caterpillar Information System:
C280-08 Tier 4 Engine Fuel Filter Housings - Remove and Install
3412 Generator Set Oil Pressure Is Low
794 AC Off-Highway Truck Field Assembly Front Axle - Install
2015/06/12 A New Speed Controller and Actuator Are Available for Certain G3400 and G3500 Engines {1264, 1908}
3412 Generator Set Engine Top Speed Is Not Obtained
C280-08 Tier 4 Engine Water Pump Seal - Remove
2015/05/29 Cat® Reman Announces the Availability of Remanufactured Fuel Check Valves Assemblies for G3600 Engines {1106}
2015/06/26 Cat® Reman Is Announcing an Appearance Change to the EI550 Classic, Bridge, and ACERT Electronic Unit Injectors for Certain Truck Engines {1290}
2015/06/05 Cat Reman Is Announcing an Appearance Change to the EI550 Classic, Bridge, and ACERT Electronic Unit Injectors for Certain Commercial Engines {1290}
2015/06/04 Cat® Reman Is Announcing an Appearance Change to the EI550 Classic, Bridge, and ACERT Electronic Unit Injectors for Certain Machine Engines {1290}
C280-08 Tier 4 Engine Water Pump Seal - Install
797F Off-Highway Truck Field Assembly Automatic Lubrication - Install - Service Center
3512C Generator Set Engine Turbocharger - Assemble
3412 Generator Set Power Is Intermittently Low or Power Cutout Is Intermittent
Reuse & Salvage Procedure for Off-Highway Truck Accumulators {0374, 0599, 0679, 0738, 4269, 4331, 5077} Reuse & Salvage Procedure for Off-Highway Truck Accumulators {0374, 0599, 0679, 0738, 4269, 4331, 5077}
3516C Generator Set Engines Air Shutoff - Remove and Install
349F and 352F Excavators Machine System Specifications Pump Coupling
3512C Engines for 785C Off-Highway Trucks with Dynamic Gas Blending Electrical Power Supply - Test
3412 Generator Set Sensor Signal (Analog, Active) - Test
C280-08 Tier 4 Engine Priority Valve - Remove and Install
2015/06/23 A New Information Display is Now Used For Certain Cat® Products {7490}
2015/06/05 Recommendations for Cold Weather Operation for C7.1 Generator Set {1225, 1317, 1331}
C280-08 Tier 4 Engine Flywheel and Ring Gear - Remove and Install
3512C Generator Set Engine Aftercooler - Remove and Install