Starting with Jump Start Cables
Show/hide table
不正确的跨接起动电缆连接会引起爆炸,造成人身伤害。 防止在蓄电池周围产生火花。 火花会引起气体爆炸。 不要让跨接起动电缆端部互相接触或与发动机接触。 |
如果安装未配备有备用蓄电池系统,则可能需要借助外部电源起动发动机。
Show/hide table
注意 |
---|
使用一个与电起动马达有相同电压的蓄电池电源。 跨接起动只允许使用相同电压。 使用更高电压会损坏电气系统。 不要反向连接蓄电池电缆。 否则交流发电机可能损坏。 接地电缆要在最后连接并要最先断开。 使用外部电源起动发动机前,确保主电源开关断开。 将跨接起动电缆连接至准备要起动的发动机上之前,先关闭所有电气附件。 |
- 将起动开关转至断开。 关闭所有附件。
- 将跨接起动电缆的一个正极端连接到已放电蓄电池的正极电缆端子上。 将跨接起动电缆的另一正极端连接到电源的正极电缆端子上。
- 将跨接起动电缆的一个负极端连接到电源的负极端子。 将跨接起动电缆的另一负极端连接到发动机缸体或底盘接地上。 这一步骤有助于防止一些蓄电池产生的易燃气体被潜在火花点燃。
- 起动发动机。
- 在停转的发动机起动后,马上以相反顺序断开跨接起动电缆。
注: 起动后,如果交流发电机或蓄电池充电器发生故障,则可能会需要一个独立电源以运转发动机。
Caterpillar Information System:
G3304B and G3306B Engines Before Starting Engine
G3516 Petroleum Engine Control Panel - Inspect/Test
C15 and C18 Petroleum Generator Sets Refill Capacities
XQ60 Rental Generator Set Sensors and Electrical Components
C3.4B Industrial Engine Sensors and Electrical Components - Aftertreatment
C15 Petroleum Engines Electronic Control Module - Remove and Install
G3500J Engines Refill Capacities
3116 and 3126 Marine Engines Coolant - Change
C4.4 Industrial Engine Exhaust Elbow - Remove and Install - Top Mounted and Side Mounted Turbocharger Exhaust Elbow
C27 Generator Set Hoses and Clamps - Inspect/Replace
C3.4B Industrial Engine Monitoring System - Table for the Indicator lamps
C27 Generator Set Generator Operation
C15 Petroleum Engines Electrical Power Supply - Test
G3304B and G3306B Engines Engine Performance - Test
C15 Petroleum Engines Air Shutoff - Remove and Install
G3500 Engines Coolant Level - Check
G3500 Engines Coolant (DEAC) - Change
300.9D and 300.9D VPS Mini Hydraulic Excavator Engine Valve Lash - Check/Adjust
C4.4 Industrial Engine Turbocharger - Install - Top Mounted Turbocharger
C4.4 Industrial Engine Turbocharger - Remove - Top Mounted Turbocharger
C4.4 Industrial Engine Turbocharger - Remove - Side Mounted Turbochargers
C4.4 Industrial Engine Turbocharger - Install - Side Mounted Turbochargers
2011/04/04 An Updated Procedure for Manual Engine Shutdown in the Engine Operation and Maintenance Manual (OMM) Is Available {1000}
C15 and C18 Petroleum Generator Sets Control Panel - Inspect/Test