ECM Harness Connector Terminals
电子控制模块 (ECM) 使用 64 端子的接头与配线线束相连。
Show/hide table
图 1 | g01746473 |
接头针脚 (从后端视图) 的布局 |
线束接头端子的拆卸与安装
端子拆卸
Show/hide table
所需工具     | |||
工具     | 零件号     | 零件描述     | 数量     |
A     | 266-1683     | 拆卸工具     | 1     |
Show/hide table
图 2 | g01784793 |
拆下端子位置固定件 |
- 将接头从 ECM 上拆下。 请参阅拆解和组装, "电子控制模块 - 拆卸和安装"。
- 使用平口螺丝刀 (1) 拆下接头 (3) 端子定位部件 (2) 。
注: 不要使用工具 (A) 拆下端子定位部件。
- 将工具 (A) 插入与端子相邻的孔内,从而松开锁定装置。
注: 确保工具与接头表面垂直。
Show/hide table
图 3 | g01784822 |
拆卸工具 |
- 将工具固定就位,并轻轻拉动导线,从而从接头 (3) 后部拆下端子。
- 从接头 (3) 正面拆下工具 (A) 。
注: 如果必须更换端子,必须使用零件号 267-9572。
端子插入
- 将端子插入接头 (3) 的后部,一直到端子与锁定装置扣合。
- 轻轻拉动导线,从而确保锁定装置将端子固定。
- 将两个端子定位部件 (2) 装入接头 (3) 侧部。
- 将接头与 ECM 相连。 请参阅拆解和组装, "电子控制模块 - 拆卸和安装"。
Caterpillar Information System:
345C MHPU Mobile Hydraulic Power Unit Machine Systems Swivel - Assemble
C1.5 and C2.2 Generator Set Engines Connecting Rod Bearings - Install
C1.5 and C2.2 Generator Set Engines Connecting Rod Bearings - Remove
C15 Generator Set Engines E255 Diagnostic Reset
C15 Generator Set Engines Ether Injection System - Test
3412 Generator Set Engines Fuel Transfer Pump
3412 Generator Set Engines Fuel Transfer Pump
345C MHPU Mobile Hydraulic Power Unit Machine Systems Swivel - Disassemble
Using Lock-N-Stitch Procedures for Casting Repair {0676, 0685} Using Lock-N-Stitch Procedures for Casting Repair {0676, 0685}
3412 Generator Set Engines Fuel Injection Pump
C15 Generator Set Engines 5 Volt Engine Pressure Sensor Supply Circuit - Test
C1.5 and C2.2 Generator Set Engines Pistons and Connecting Rods - Install
C15 and C18 Engines for Caterpillar Built Machines Water Temperature Regulator Housing
345C MHPU Mobile Hydraulic Power Unit Machine Systems Swing Drive - Disassemble
C1.5 and C2.2 Generator Set Engines Coolant Temperature Switch - Remove and Install
C1.5 and C2.2 Generator Set Engines Engine Oil Pressure Switch - Remove and Install
C15 Petroleum Generator Set Engines Flywheel Housing
C1.5 and C2.2 Generator Set Engines V-Belts - Remove and Install
345C MHPU Mobile Hydraulic Power Unit Machine Systems Swing Drive - Assemble
345B Excavator Fire Extinguisher Location
C27 and C32 Generator Set Engines Poor Acceleration or Response
C175 Generator Set Engines Flywheel - Remove and Install
C9-XQ300 Rental Generator Set Battery Disconnect Switch
C9-XQ300 Rental Generator Set Circuit Breakers - Reset