2008/11/17 Caterpillar


Policy on Testing of Fuel Injectors and Fuel Nozzles {1251}

Usage:

769C 01X
Caterpillar Products:
  • All
  • Do not use any off-engine diagnostic test on fuel injectors or fuel nozzles prior to installation of the injectors or nozzles. Caterpillar Fuel Systems Division does not recommend the use of any test equipment that is outside of the factory for field evaluation of injectors and nozzles prior to the installation of the injectors or nozzles.

    The Marketing and Product Support Division supports the recommendation of the Fuel Systems Division.

    Fuel Injectors

    • The 6V-4022 Fuel Injector Tester was cancelled and replaced by components that were also cancelled or discontinued.

    • The 1U-6661 Pop Tester Gp was discontinued.

    The testers were rendered obsolete by increased injection pressures and by performance requirements for injectors. The inaccuracy of the testers' use with improved injectors resulted in replacement of good injectors. This caused warranty claims for injectors with no fault.

    The service literature that was related to the testers has been removed from the Service Information System (SIS) and from Media Logistics. References to the testers and to the removed service literature have also been removed or the references are in the process of being removed.

    The Marketing and Product Support Division will no longer accept any warranty claims on any injectors that are evaluated by the above testers or by any other commercial device that is used for the testing of injectors.

    Fuel Nozzles

    The 5P-4150 Nozzle Testing Group is used for the bench testing of fuel nozzles only after the nozzles have been tested in the engine and the performance of the nozzles are questionable.

    The 5P-4150 Nozzle Testing Group is still serviceable.

    Do not use the 5P-4150 Nozzle Testing Group with fuel injectors.

    The Marketing and Product Support Division will no longer accept any warranty claims on any nozzles that are evaluated prior to being tested by engine operation.

    Caterpillar Information System:

    797B Off-Highway Truck Mirror
    416E Backhoe Loader Shipping the Machine
    416E Backhoe Loader Leaving the Machine
    12K, 140K, 140K Series 2 and 160K Motor Graders Hydraulic and Steering System Steering System
    416E Backhoe Loader Stabilizer Control
    416E Backhoe Loader Backup Alarm
    2008/11/17 Policy on Testing of Fuel Injectors and Fuel Nozzles {1251}
    416E Backhoe Loader Plate Locations and Film Locations
    416E Backhoe Loader Safety Messages
    2009/03/02 Update to the Testing and Adjusting , "Limit Switch (Stop Light) - Adjust" {1432, 1435, 4269}
    785D Off-Highway Truck/Tractor Engine Supplement Engine and Torque Converter - Separate and Connect
    785D Off-Highway Truck/Tractor Engine Supplement Engine and Torque Converter - Install
    2008/11/01 Policy on Testing of Fuel Injectors and Fuel Nozzles {1251}
    416E Backhoe Loader Lift Cylinder Brace - Connect and Disconnect
    416E Backhoe Loader Loader Bucket, Cylinder, and Linkage Bearings - Lubricate
    14H and 16H Motor Graders Hydraulic and Steering System Pump Efficiency (Gear Pumps) - Test
    EquipmentManager Dealer Administrator Manual Active Fleet
    R1700G Load Haul Dump Circuit Breakers - Reset
    R2900G Load Haul Dump Circuit Breakers - Reset
    2009/02/23 New Oil Pump {1151, 1162, 1206}
    CB54, CB54 XW and CB64 Vibratory Compactor Propel System Brake Pump
    793F and 797F Off-Highway Trucks Chassis Electronic Control System System Schematic
    2008/12/01 Water Temperature Regulator {1355, 1380}
    IT38H Integrated Toolcarrier and 938H Wheel Loader Alternator Air Vent Line and Screen - Clean
    Back to top
    The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
    CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.