Alternator - Remove and Install
拆卸步骤
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
注: 在所有导线上做上识别标记,以便于安装。
- 将电源断路开关转至断开位置。
- 断开电缆组件 (1) 。
Show/hide table
图 1 | g01315499 |
- 断开线束组件 (2) 。
- 断开电缆组件 (3) 。
- 拆下护罩 (4) 。
Show/hide table
图 2 | g01315502 |
- 松开螺母 (5) 。
Show/hide table
图 3 | g01315943 |
- 松开螺母 (6) 以便释放皮带 (8) 上的张紧力。
- 拆下螺栓 (7) 和隔套。
- 拆下螺栓 (9) 和隔套。
- 拆下交流发电机 (10) 。
安装步骤
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
- 安装交流发电机 (10) 。
Show/hide table
图 4 | g01315943 |
- 安装螺栓 (9) 和隔套。
- 安装螺栓 (7) 和隔套。
- 安装螺栓 (8) 。 拧紧螺母 (6) 。
- 拧紧螺母 (5) 。
- 安装护罩 (4) 。
Show/hide table
图 5 | g01315502 |
- 连接电缆组件 (3) 并拧紧电缆组件 (3) 至扭矩为 18.2 ± 2.4 N·m (161.1 ± 21.3 lb in)。
Show/hide table
图 6 | g01315499 |
- 连接导线组件 (2) 。
- 连接电缆组件 (1) 并拧紧电缆组件 (1) 至扭矩为 4.4 ± 1 N·m (3.3 ± 1 lb ft)。
Caterpillar Information System:
785D OEM Off-Highway Truck Machine Systems Check Valve (Service Brake) - Remove and Install
IT62H Integrated Toolcarrier and 950H and 962H Wheel Loaders Machine Systems Secondary Steering Valve - Install
IT62H Integrated Toolcarrier and 950H and 962H Wheel Loaders Machine Systems Secondary Steering Valve - Remove
725 and 730 Articulated Trucks Machine Systems Steering Cylinder - Remove and Install
Instructions for Converting Intermittent Saw to Hot Saw{5050, 6327, 7000} Instructions for Converting Intermittent Saw to Hot Saw{5050, 6327, 7000}
PS-150B and PS-200B Paving Compactors Fuel System Water Separator - Drain
587R Pipelayer Fairlead Sheave - Lubricate
PS-150B and PS-200B Paving Compactors Parking Brake Manual Release
AP-1055D and BG-2455D Asphalt Pavers Propel System Lever (Propel Control) and Electronic Sensor - Test
2005/07/11 A New Hopper Lift Cylinder is Now Used on the Asphalt Pavers {7562}
AP-1055D and BG-2455D Asphalt Pavers Propel System Hydraulic Schematic (Propel System)
583T Pipelayer Ether Starting Aid Cylinder - Replace
793D Off-Highway Truck/Tractor Relay Valve (Brake) - Remove
793D Off-Highway Truck/Tractor Relay Valve (Brake) - Install
AP-1055D and BG-2455D Asphalt Pavers Conveyor Systems Introduction
793D Off-Highway Truck Suction Screen (Rear Axle Lubrication) - Clean
AP-1055D and BG-2455D Asphalt Pavers Conveyor Systems Location of Electrical Components
AP-1055D and BG-2455D Asphalt Pavers Conveyor Systems Location of Hydraulic Components
AP-1055D and BG-2455D Asphalt Pavers Conveyor Systems Conveyor System
C27 and C32 Engines for Caterpillar Built Machines Injector Solenoid Circuit - Test
PS-150B and PS-200B Paving Compactors Daily Inspection
587R Pipelayer Hook and Wire Cable - Inspect
C9 Engine for Caterpillar Built Machines Fuel Priming Pump - Remove and Install
AP-1055D and BG-2455D Asphalt Pavers Propel System Harness (Speed Potentiometer) and Electronic Sensor - Test