Stator - Test
Show/hide table
Illustration 1 | g01066106 |
(6) Stator (7) Stator leads (8) Stator frame |
Stator Winding Continuity Test
- Connect the multimeter leads between each combination of two stator leads (7) : (A to B), (B to C) and (C to A). Make a note of each measurement.
- The three measurements should be approximately 0.063 ohms.
- Replace the stator (6) if any of the measurements are incorrect. If a measurement is too low, the stator (6) is shorted. If a measurement is too high, the stator (6) is open.
Stator Winding Ground Test
- Set the multimeter to the 20 M ohm resistance scale. Measure the resistance between each stator lead (7) and the stator frame (8) : (A to 8), (B to 8) and (C to 8) .
- Each measurement should be greater than 100 K Ohms (0.100 M Ohms).
- If any of the three measurements are low, the stator (6) is shorted to the stator frame (8). Replace the stator if a short is measured.
Caterpillar Information System:
SCJ and 8SC Series Alternators Field Winding - Test
SCJ and 8SC Series Alternators Capacitor - Test
G3520C and G3520E Engines Temperature Sensor - Thermocouple
3126B Petroleum Engine Throttle Position Sensor Circuit - Test
C-10 and C-15 Petroleum Engines Injector Solenoid Circuit - Test
G3408C and G3412C Engines Engine Oil Level - Check
2004/04/01 An Unknown Diagnostic Fault Code is Displayed on the CAT Electronic Service Tool Display {1901}
G3408C and G3412C Engines Starting with Jump Start Cables
G3408C and G3412C Engines Before Starting Engine
G3408 and G3412 Engines Engine Operation
C-10 and C-15 Petroleum Engines Ether Injection System - Test
C15 Petroleum Engine After Stopping Engine
3516B and 3516B High Displacement Engines for 994D and 994F Wheel Loaders Accessory Drive (Upper Left Hand)
3126B Petroleum Engine Diagnostic Flash Code Retrieval
C-15 Petroleum Engine Auxiliary Water Pump - Disassemble
C-15 Petroleum Engine Auxiliary Water Pump - Assemble
3126B Petroleum Engine Refill Capacities and Recommendations
C7 On-highway Engine Air Compressor
G3520C and G3520E Engines Water Pump
3126B Petroleum Engine Engine Oil and Filter - Change
C-15 Petroleum Engine Aftercooler - Install
C-15 Petroleum Engine Aftercooler - Remove
C9 On-highway Engine Camshaft
C-15 Petroleum Engine Fuel Priming Pump - Remove and Install