Engine Operation
正确的操作和保养是获得发动机最大使用寿命和经济性的关键因素。 遵循本操作和保养手册中的说明,以便最大限度降低使用费用和延长发动机的使用寿命。
发动机运行时频繁观察仪表显示。 定期在记录簿上记录仪表数据。 将数据与发动机正常运行的技术规格比较。 经常对比这些数据有助于觉察发动机的性能变化。
调查研究仪表读数的任何显著变化。 监测发动机运行并在发现偏差时采取措施。
发动机带负载运转的同时经常检查仪表和从动设备。 发动机可以在满载下长时间运行。
在低怠速或在小负载下长时间运转,可能造成机油消耗量增加并且在气缸中形成积碳。 积碳会造成以下影响:
- 功率损失
- 性能不良
- 加速部件磨损
Caterpillar 发动机可以在非常轻的负载(扭矩)下运行有限的一段时间而不会造成有害的影响。 表 1 列出在不同负载下运行的时间限制。
注: 不遵循这些原则会导致气缸积炭增加,并且可能在气门上形成沟槽。 这些状况和故障未包含在保修内!
在较低负载下运行的时间限制期满后,让发动机在高于 70 % 的扭矩下至少运行 2 小时。
例如,发动机在 20 % 的额定扭矩下运行。 发动机在这个负载因数下运转最长是半小时。 在半小时之后,应使这台发动机在大于 70 % 负载因数下至少运转 2 小时。
为使发动机的保养需求保持在最低程度,应遵照表 1 所列准则。
Show/hide table
低负载运行的时间限制 | ||
发动机扭矩 | NA 发动机 | TA 发动机 |
0 到 30% | 1/2 小时 | 1/2 小时 |
31 到 60% | 2 小时 | 2 小时 |
61 到 70% | 24 小时 | 连续功率(1) |
71 到 100% | 连续功率 | 连续功率(1) |
Show/hide table
(1) | TA 发动机连续运行时,歧管空气压力必须大于大气压力。 |
Caterpillar Information System:
C-10 and C-15 Petroleum Engines Ether Injection System - Test
C15 Petroleum Engine After Stopping Engine
2004/06/01 Realignment of Air System Components is Recommended. {1063}
C18 Generator set and C18 Marine Engines Heat Exchanger - Assemble - Without Fuel Cooler
C18 Generator set and C18 Marine Engines Heat Exchanger - Disassemble - With Fuel Cooler
C-10 and C-15 Petroleum Engines Engine Speed/Timing Sensor Circuit - Test
SCJ and 8SC Series Alternators Charging System
SCJ and 8SC Series Alternators Service Tools
C-12 Generator Set Engine CID 0268 FMI 02 Check Programmable Parameters
G3300 Engines Cooling System Coolant (NGEC) - Change
2004/05/01 New Water Lines Groups are Used for Venting of the Separate Circuit Aftercooler {1380}
C15 and C18 Engines for Caterpillar Built Machines Flywheel Housing
G3408C and G3412C Engines Before Starting Engine
G3408C and G3412C Engines Starting with Jump Start Cables
2004/04/01 An Unknown Diagnostic Fault Code is Displayed on the CAT Electronic Service Tool Display {1901}
G3408C and G3412C Engines Engine Oil Level - Check
C-10 and C-15 Petroleum Engines Injector Solenoid Circuit - Test
3126B Petroleum Engine Throttle Position Sensor Circuit - Test
G3520C and G3520E Engines Temperature Sensor - Thermocouple
SCJ and 8SC Series Alternators Capacitor - Test
SCJ and 8SC Series Alternators Field Winding - Test
SCJ and 8SC Series Alternators Stator - Test
3516B and 3516B High Displacement Engines for 994D and 994F Wheel Loaders Accessory Drive (Upper Left Hand)
3126B Petroleum Engine Diagnostic Flash Code Retrieval