Engine Water Pump - Inspect
A water pump that has failed might cause severe engine overheating. Severe engine overheating could result in the following problems:
- Cracks in the cylinder head
- Piston seizure
- Other potential engine damage
Show/hide table
Illustration 1 | g00671711 |
Open the engine compartment.
The water pump is located on the engine block at the front of the engine.
Show/hide table
Illustration 2 | g00671723 |
Visually inspect the water pump for leaks. If leaks are found, all the seals must be replaced.
Note: See the Service Manual, KENR7020 for more information.
Close the engine compartment.
Caterpillar Information System:
CB-535B Vibratory Compactor Engine Valve Lash - Check
CB-535B Vibratory Compactor Engine Oil and Filter - Change
CB-535B Vibratory Compactor Engine Oil Sample - Obtain
CB-535B Vibratory Compactor Engine Oil Level - Check
1999/12/06 New Service Magazine Format {0374, 1000, 7000}
CB-535B Vibratory Compactor Engine Mounts - Inspect
2000/01/10 Oil Filler Cap is Now Attached with a Lanyard {1316}
CB-535B Vibratory Compactor Engine Crankcase Breather - Clean - Engine Crankcase Breather Hose
CB-535B Vibratory Compactor Engine Air Filter Service Indicator - Inspect
CB-535B Vibratory Compactor Engine Air Filter Secondary Element - Replace
CB-535B Vibratory Compactor Engine Air Filter Primary Element - Clean/Replace
CP-433C, CS-431C and CS-433C Paving Compactors Fuel System Water Separator - Drain
CB-535B Vibratory Compactor Drum Offset Control
3054B Industrial Engine Engine Oil Filter Base - Remove
3054B Industrial Engine Engine Oil Filter Base - Install
3054B Industrial Engine Engine Oil Filter Base - Disassemble
TH62, TH63, TH82 and TH83 Telehandlers Braking System Service Brake Air - Purge
1999/12/20 Change to Tightening Procedure for Cylinder Head Bolts in Specifications, RENR1217 and Specifications, SENR5182 {1100}
TH62, TH63, TH82 and TH83 Telehandlers Hydraulic System Towing Hitch System - If Equipped
2000/02/21 New Air Cleaner Support and Exhaust Tube Bracket Available for 24H Motor Grader, D10R Track-Type Tractor, and the 651E and 657E Wheel Tractor Scrapers {1051, 1061}
2000/01/03 Locations Where New Tube Assemblies Are Used {1274}
2000/02/07 New Procedure to Test DASA 280C on Excavators With the HH65 Harvester Head {7610, 7620}
C-9 Engine for TK711, TK721, TK722, TK732, TK741, TK751, and TK752 Track Feller Bunchers CID 0261 FMI 13 Engine Timing Calibration required
988G Wheel Loader Power Train NoSPIN Differential