Coolant Pressure Is Low
使用本程序对冷却液压力低进行故障诊断与排除,或者在以下事件代码为激活状态时使用本程序。 关于事件代码的信息,请参阅故障诊断与排除, "事件代码"。 必须进入 Caterpillar 电子技师(ET)上的发动机监控系统才能查看这些代码的当前触发点。 关于发动机监控系统的信息,请参阅故障诊断与排除, "发动机监控系统"。
Show/hide table
事件代码 | ||
---|---|---|
说明 | 激活代码的条件 | 系统响应 |
E228(3) 水套水出口压力低 | 冷却系统压力降至编程延迟时间的触发点以下。 | 记录该代码。
停机输出启动。 发动机停机。 |
- 冷却液液位低
- 冷却液流量不足
检查冷却液液位。 如果冷却液液位太低,检查冷却系统有无泄漏。 如有必要,添加冷却液。
停止发动机并使用 Cat ET 以观察水套水出口处的压力。 然后在发动机运转时,观察读数。
如果读数不合理或读数不在技术规范内,在水套水出口靠近压力传感器处安装压力表。 将仪表读数与 Cat ET 读数相比较。
务必使用准确的仪表进行您的测量。 使用没有正确标定的仪表可能会导致错误的故障诊断。
如果出自比照仪表的读数与 Cat ET 的不一致,排除水套水出口压力传感器电路的故障。 请参阅故障诊断和排除, "传感器信号(PWM)- 测试"。
如果比照仪表的读数与 Cat ET 的基本一致,检查以下状况:
- 水温调节器的正常运行
- 散热器、热交换器和发动机机油冷却器堵塞
- 水套水泵的叶轮损坏
进行必要的修理。
Caterpillar Information System:
G3520B Industrial Engines Coolant Temperature Is High
C15 On-Highway Engine Compression Brake Lash - Adjust
G3520B Industrial Engines Control Module - Replace
G3520B Industrial Engines ECM - Replace
C32 Marine Propulsion Engines Sensor Supply - Test
320D and 323D Excavators Machine System Specifications Stick
C15 On-Highway Engine Cylinder Head - Install
C4.4 (Mech) Industrial Engine Turbocharger - Inspect
G3520B Industrial Engines Cat Data Link - Test
G3520B Industrial Engines Detonation - Test
G3520B Industrial Engines Electrical Power Supply - Test
C15 On-Highway Engine Clean Gas Induction Pressure Sensor - Remove and Install
G3500B Engines Coolant Temperature Is Low
3500 and 3500B Engines Camshaft Roller Followers - Inspect
Inspecting and Repairing the Air Inlet and Exhaust System After Improper Fueling{1000, 1052, 1053, 1061, 1087} Inspecting and Repairing the Air Inlet and Exhaust System After Improper Fueling{1000, 1052, 1053, 1061, 1087}
G3520B Industrial Engines Timing - Calibrate
C15 and C18 Petrolem Generator Set Engines Speed/Timing - Test
G3500B Engines Engine Does Not Crank
C32 Marine Propulsion Engines Sensor Signal (PWM) - Test
C15 On-Highway Engine Fumes Disposal Group - Remove and Install
2007/07/02 The Firing Order has Changed for New Engines {1000}
3512C HD and 3516C HD IPP Rental Power Modules Inlet Air Is Restricted
C32 Marine Propulsion Engines CAN Data Link - Test
3408E and 3412E Engines for Caterpillar Built Machines Camshaft