Refrigerant Compressor - Remove and Install
拆卸步骤
Show/hide table
接触制冷剂会使人受伤。 接触制冷剂会造成冻伤。 让手、脸避开,有助于防止受伤。 制冷管路被打开时,即使压力计显示系统中已经没有制冷剂,也要始终戴着护目镜。 拆卸管件时,务必小心谨慎。 慢慢地拧松接头。 如果系统内仍有压力,就要把它缓慢地释放到一个通风良好的地方去。 通过燃着的香烟吸入制冷剂会使人受伤或死亡。 通过燃着的香烟或其他抽烟方法吸入空调制冷气体,或者,吸入空调制冷气体接触明火而形成的烟雾,都会造成对人体的伤害 或死亡。 维修空调时,或者,在任何可能存在制冷气体的地方都不要抽烟。 采用经过认可的回收和循环利用车妥善地从空调器中取出制冷剂。 |
注: 在所有管路、软管、导线及管路上安装盖或螺塞,以防止异物进入系统。
- 排空空调系统。
- 松开螺栓 (1) 、 (2) 和 (3) 。
Show/hide table
图 1 | g00623741 |
- 松开调整螺母 (4) 。 移动制冷剂压缩机,以释放传动带 (5) 的张力。 拆下皮带 (5) 。
Show/hide table
图 2 | g00623767 |
- 断开配线线束 (7) 。 卸下束线带并断开配线线束 (8) 。
Show/hide table
图 3 | g00623769 |
- 断开两条管路 (6) 。
- 卸下螺栓 (1) 、 (2) 和 (3) 。 卸下制冷剂压缩机 (10) 。
安装步骤
- 将制冷剂压缩机 (10) 放置到位。 安装螺栓 (1) 、 (2) 和 (3) 。 请勿拧紧螺栓 (1) 、 (2) 和 (3) 。
Show/hide table
图 4 | g00623769 |
- 连接两条管路 (6) 。
- 连接配线线束 (8) 并安装束线带。 连接配线线束 (7) 。
- 安装螺栓 (5) 。 拧紧调节螺母 (4) 。
Show/hide table
图 5 | g00623767 |
- 拧紧螺栓 (1) 、 (2) 和 (3) 。
Show/hide table
图 6 | g00623741 |
- 加注空调系统。
Caterpillar Information System:
D9R Track-Type Tractor Machine Systems Air Conditioner Dryer - Remove and Install
D9R Track-Type Tractor Machine Systems Air Conditioner and Heater Fan Motor - Remove and Install
D9R Track-Type Tractor Machine Systems Rollover Protective Structure (ROPS) - Remove and Install
D9R Track-Type Tractor Machine Systems Steering Motor - Assemble
D9R Track-Type Tractor Machine Systems Steering Motor - Disassemble
D9R Track-Type Tractor Machine Systems Steering Motor - Install
D9R Track-Type Tractor Machine Systems Steering Motor - Remove
D9R Track-Type Tractor Machine Systems Governor Control Linkage and Decelerator - Install
D9R Track-Type Tractor Machine Systems Governor Control Linkage and Decelerator - Remove
D9R Track-Type Tractor Machine Systems Bulldozer and Tilt Control Linkage - Remove
D9R Track-Type Tractor Machine Systems Bulldozer and Tilt Control Linkage - Install
D9R Track-Type Tractor Machine Systems Quick-Drop Valve - Remove
D9R Track-Type Tractor Machine Systems Refrigerant Condenser - Remove and Install
3046 Engine For Caterpillar Built Machines Housing (Front) - Install
623F Wheel Tractor-Scraper Power Train Retarder Hydraulic Control Valve - Disassemble
994D Air System Wheel Loader Air Dryer - Check
545 Wheel Skidder Hydraulic and Steering System Steering Cylinder
515 Wheel Skidder and 525 Wheel Skidder Transmission and Grapple Electronic Control System Start Switch (Key)
623F Wheel Tractor-Scraper Power Train Retarder Hydraulic Control Valve - Assemble
515 Wheel Skidder and 525 Wheel Skidder Transmission and Grapple Electronic Control System Start Relay
D9R Track-Type Tractor Stopping the Engine
963B Track-Type Loader Engine Oil and Filter - Change
D9R Track-Type Tractor Machine Systems Refrigerant Accumulator - Remove and Install
D9R Track-Type Tractor Engine Air Filter Primary Element - Clean/Replace