Updated Predelivery/Revisit Checklists Are Now Used Caterpillar

Updated Predelivery/Revisit Checklists Are Now Used

Usage:

Updated Predelivery/Revisit Checklists Are Now Used

CONFIDENTIAL TIBU3688-00

Show/hide table

TECHNICAL INFORMATION BULLETIN	October 02, 2002
Earthmoving Compactor - All Track-Type Tractor - All Track-Type Loader - All Pipelayer - All Wheel Tractor-Scraper - All Motor Grader - All Excavator - All Forest Products - All Wheel Loader - All Wheel Tractor - All Wheel Skidder - All Integrated Toolcarrier - All Asphalt Paver - All Telehandlers - All Agricultural Tractor - All Backhoe Loaders - All
	Component Code: 1401

SUBJECT: Updated Predelivery/Revisit Checklists Are Now Used

The Predelivery/Revisit Checklists have been updated. The portion of the Predelivery/Revisit Checklists that has been modified is the Battery Check line. The Battery Check line is located in the Engine row (under the Check Service Points and Fluid Levels column).

A space has been added to the Battery Check line in order to record the Open Circuit Voltage (OCV). To ensure a properly charged battery, the Open Circuit Voltage must be greater than 12.45 VDC after removing the surface voltage. If the OCV is less than 12.45 VDC, perform a battery test. Refer to Special Instruction, SEHS7633, "Battery Test Procedure" and SEHS9326, "Battery Test Sheet".

Show/hide table

Updated Predelivery/Revisit Checklists
Checklist Number	Checklist Name	Machines
01-087716	Predelivery/Revisit Checklist	Compactors
01-087717	Predelivery/Revisit Checklist	Track-Type Tractors, Track-Type Loaders, Pipelayers
01-087719	Predelivery/Revisit Checklist	Scrapers
01-087720	Predelivery/Revisit Checklist	Motor Graders
01-087721	Predelivery/Revisit Checklist	Excavators, Loggers, Front Shovels, Forestry Swings
01-088680	Predelivery/Revisit Checklist	Wheel Loaders, Wheel Dozers, Skidders, Integrated Tool Carriers
01-088724	Predelivery/Revisit Checklist	Profilers, Trimmers
01-089423	Predelivery/Revisit Checklist	Asphault Pavers
01-040276	Predelivery/Revisit Checklist	Telehandlers
01-089067	Predelivery/Revisit Checklist	Belted Ag Tractors
01-089089	Predelivery/Revisit Checklist	Backhoe Loaders
01-087891	Comprobaciones antes y despues de la entraga	Excavadoras, Taladores Forestales?
01-087892	Comprobaciones antes y despues de la entraga	Montoniveladoras
01-087896	Comprobaciones antes y despues de la entraga	Cargadores de Ruedas, Tractores de Ruedas?
01-089390	Conpactadores Informe Del Servicio de le entrega

COPYRIGHT 2002 CATERPILLAR
ALL RIGHTS RESERVED

Caterpillar Information System:

A New Radiator and Shroud are Used A New Radiator and Shroud are Used

Power Train Oil Filter Bypass Alarm Activates at a Lower Pressure than Intended Power Train Oil Filter Bypass Alarm Activates at a Lower Pressure than Intended

Tilt Cylinder Dump Noise Tilt Cylinder Dump Noise

WIRING DIAGRAM FOR INSTALLING THE MARINE POWER DISPLAY WIRING DIAGRAM FOR INSTALLING THE MARINE POWER DISPLAY

Caterpillar is releasing replacement software for PCS version 2.07A and 2.07AR software (Cat p/n 213-8794 and 213-8799 respectively) Caterpillar is releasing replacement software for PCS version 2.07A and 2.07AR software (Cat p/n 213-8794 and 213-8799 respectively)

CASE DRAIN RETURN SCREEN ON D11R AND D11R CARRYDOZER HYDRAULIC TANK MUST BE CHECKED CASE DRAIN RETURN SCREEN ON D11R AND D11R CARRYDOZER HYDRAULIC TANK MUST BE CHECKED

Cracks have been found in the radome of the 167-8930 GPS Antenna and the 194-8015 GPS Antenna Cracks have been found in the radome of the 167-8930 GPS Antenna and the 194-8015 GPS Antenna

Temporary Change to the PS41004 Hood Skin Repair Procedure for D9R Track-Type Tractors Temporary Change to the PS41004 Hood Skin Repair Procedure for D9R Track-Type Tractors

PREVENTING CRACKS IN THE REAR TRACK ROLLER FRAME PREVENTING CRACKS IN THE REAR TRACK ROLLER FRAME

The Pins for the Sidebar Bend or Break The Pins for the Sidebar Bend or Break

USE THE 2P-4005 ENGINE OIL FILTER ASSEMBLY TO REPLACE 1R-0716 ENGINE OIL FILTER ASSEMBLY USE THE 2P-4005 ENGINE OIL FILTER ASSEMBLY TO REPLACE 1R-0716 ENGINE OIL FILTER ASSEMBLY

Early Detection Can Prevent Crack Growth into A-Pin Bore Early Detection Can Prevent Crack Growth into A-Pin Bore

REPLACEMENT OF THE FUEL RATIO CONTROL DIAPHRAGM REPLACEMENT OF THE FUEL RATIO CONTROL DIAPHRAGM

CHECK FOR PROPER TORQUE ON THE ELECTRIC STARTER MORTOR NUTS CHECK FOR PROPER TORQUE ON THE ELECTRIC STARTER MORTOR NUTS

8F-3469 O-Ring Seal Failures May Be Caused by a Transmission Clutch Shaft That Is Too Short 8F-3469 O-Ring Seal Failures May Be Caused by a Transmission Clutch Shaft That Is Too Short

Trunnion Support for the Rear Oscillating Axle Should be Inspected for Cracks Trunnion Support for the Rear Oscillating Axle Should be Inspected for Cracks

Use of the Engine Shutdown Switch or Low Engine Speeds Can Cause Loss of Speed Sensor Diagnostic Codes Use of the Engine Shutdown Switch or Low Engine Speeds Can Cause Loss of Speed Sensor Diagnostic Codes

Low Engine Speed May Be Caused by a Breather Malfunction in the Non-Metallic Fuel Cap Low Engine Speed May Be Caused by a Breather Malfunction in the Non-Metallic Fuel Cap

Autolube is Now Standard and Parts are Available Autolube is Now Standard and Parts are Available

Bypass Schedule May Be Affected when Machine Security System (MSS) Automatically Adjusts to North American Daylight Savings Time Bypass Schedule May Be Affected when Machine Security System (MSS) Automatically Adjusts to North American Daylight Savings Time

Some configuration settings in the Machine Security System (MSS) may change when MSS software release 207-6258 is upgraded to MSS software release 220-6355 Some configuration settings in the Machine Security System (MSS) may change when MSS software release 207-6258 is upgraded to MSS software release 220-6355

THE DIAGNOSTIC CODE 175-4 �ENGINE OIL TEMPERATURE SHORT TO GROUND� MAY BE A RESULT OF OVERCOOLING THE DIAGNOSTIC CODE 175-4 �ENGINE OIL TEMPERATURE SHORT TO GROUND� MAY BE A RESULT OF OVERCOOLING

Installation Of The Sitevision GPS Cable Encoder Bracket On Hydraulic Excavators Installation Of The Sitevision GPS Cable Encoder Bracket On Hydraulic Excavators

Fleet/Key Configuration Issue Using Cat ET Version 2002B Fleet/Key Configuration Issue Using Cat ET Version 2002B