Turbocharger - Remove
拆卸步骤
Show/hide table
所需工具     | |||
工具     | 零件号     | 零件说明     | 数量     |
A     | 138-7575     | 连杆支架     | 2     |
- 排空冷却液系统。 请参阅操作和保养手册, "加注容量和建议"。
Show/hide table
注意 |
---|
在检验、保养、测试、调整及维修发动机时,请小心确保盛接流出的液体。 在打开或拆解任何储有液体的部件之前,要准备好合适的容器收集液体。 有关适合收集和盛接卡特彼勒产品上的液体的工具和供应品,请参阅专门出版物, NENG2500, "卡特彼勒代理商工具目录"。 按照本地法规和条例处置所有液体。 |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
注: 为便于安装,在所有软管组件和所有管组件上做出识别标记。 塞住所有软管组件和管组件。 这将有助于防止流体渗漏,并 有助于防止污染物进入系统。
注: 塞上或盖上涡轮增压器的所有开口。 该步骤有助于防止污染物进入系统。
- 断开管组件 (1) 和 (4) 。
Show/hide table
图 1 | g01063415 |
- 断开管组件 (2) 和 (3) 。
- 卸下螺栓 (5) 。
- 将工具 (A) 和适当的起吊设备连接到涡轮增压器 (9) 和进气弯头上。
Show/hide table
图 2 | g01063422 |
- 拆下螺栓 (6) 。
- 拆下卡箍 (7) 。
- 拆下螺栓 (8) 。
- 拆下涡轮增压器 (9) 。 涡轮增压器的重量 约为 100 kg (220 lb)。
Caterpillar Information System:
3406E, C-10 and C-12 On-highway Engines 5 Volt Engine Pressure Sensor Supply Circuit - Test
C7 Marine Engine Electric Starting System - Test
C7 Engines for Caterpillar Built Machines Water Temperature Regulator - Test
C7 Marine Engine Cooling System - Inspect
C11 and C13 Engines for Caterpillar Built Machines Engine Valve Lash - Inspect/Adjust
C27 and C32 Industrial Engines Monitoring System - If Equipped
3512B and 3516B High Displacement Locomotive Engines Refill Capacities and Recommendations
2004/04/01 Revised Special Instruction, REHS2115, "Requirements for Installation of the 197-6700 Piston " is Available {1214, 1216}
3512B and 3516B High Displacement Locomotive Engines After Stopping Engine
3408E and 3412E Engines for Caterpillar Built Machines Atmospheric Pressure Sensor
C-10 Petroleum Engine Fuel System Secondary Filter - Replace
3114, 3116, 3126 Engines Rear Seal Carrier
3406E and 3456 Generator Set Engines Sensors and Electrical Connectors
G3520C and G3520E Generator Set Engines Turbocharger - Install
3406E and 3456 Generator Set Engines Engine Cranks but Will Not Start
G3520C and G3520E Generator Set Engines Turbocharger - Disassemble - Dual Turbochargers
3406E, C-10 and C-12 On-highway Engines Accelerator Pedal (Throttle) Position Sensor Circuit - Test
G3520C and G3520E Generator Set Engines Turbocharger - Assemble - Dual Turbochargers
3406E and 3456 Generator Set Engines Coolant in Engine Oil
C-15 Petroleum Engine Auxiliary Water Pump
3406E and 3456 Generator Set Engines ECM Will Not Communicate with Other Systems or Display Modules
C7 Marine Engine Cooling System - Check - Overheating
3406E, C12, C15 and C18 Marine Engines Flash Codes
2004/04/01 The Heat Exchanger Bonnet can be Rotated on Certain Applications {1379}