MID 036 - CID 0298 - FMI 02 Incorrect Service Brake Pedal Switch inputs
Conditions Which Generate This Code:
Both of the signals (normally open contact and the normally closed contact) from the Right Brake pedal switch are at the same potential. Therefore, both switch signals are at 11.5 ± 0.5 VDC or both switch signals are less than 0.5 VDC.
System Response:
The CID-FMI may be viewed on the display module or on the Caterpillar Electronic Technician (ET). The CID-FMI is logged in memory. The throttle lock feature is disabled.
Test Step 1. Perform the following diagnostic procedure: Right Brake Switch
Results:
- OK - STOP
- REPAIRED, OK - STOP
Caterpillar Information System:
325D and 329D Excavators Fuel Tank Cap and Strainer - Clean
2000/03/20 New Bolts and Torque for Securing the TOPS {7325}
2000/04/24 The Reliability of the Window Washers is Increased {7306}
2000/06/19 New Pump Drive Is Used To Improve Service Life {3108}
315C Excavator Fuel System Primary Filter (Water Separator) Element - Replace
312C, 315C, 318C, 319C, 320C, 321C, 322C, 325C, 330C and M325C Excavators and 325C MHPU and 330C MHPU Mobile Hydraulic Power Units Engine and Pump Control - V2 Using Service Mode
320C Excavator Fuel System Water Separator - Drain
312C, 315C, 318C, 319C, 320C, 321C, 322C, 325C, 330C and M325C Excavators and 325C MHPU and 330C MHPU Mobile Hydraulic Power Units Engine and Pump Control - V2 Initial Troubleshooting Procedure
320C U Excavator Fuel System - Prime
P16, P20, P25, P28, P40 and P60 Pulverizers Hydraulic Cylinder - Remove
320C U Excavator Fuel System Filter - Replace
2000/03/20 Changes to High Idle and Low Idle Information {1000}
325C and 325C L Excavator Fuel Tank Water and Sediment - Drain
320C Excavator Fuses - Replace
320C Excavator Machine Systems Bucket - Install
2000/03/20 Improved Exhaust Manifolds {1059}
320C Excavator Machine Systems Stick Bearings and Seals - Remove
303.5 Mini Hydraulic Excavator Recoil Spring
320C Excavator Hydraulic System Pump Control (Main Hydraulic) - Main Pump Regulator
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders MID 036 - CID 0548 - FMI 05 Throttle Lock Lamp open circuit
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders MID 036 - CID 0548 - FMI 06 Throttle Lock Lamp short
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders MID 036 - CID 0650 - FMI 12 Harness Code invalid
318C and 319C Excavators Hydraulic System Oil - Change
3524B Engines for 797 and 797B Off-Highway Trucks General Information (Fuel System) - Diesel