Gear Pump (Brake Cooling)
Show/hide table
图 1 | g01202898 |
端部视图 |
(1) 八根螺栓的扭矩 ... 250.8 ± 6.7 N·m (185.0 ± 5.0 lb in)
Show/hide table
图 2 | g01536875 |
剖面 A-A |
(2) 如图所示,组装轴密封件,使弹簧加载表面彼此相对。
(3) 将环开口组装在排放孔上。
Show/hide table
图 3 | g01537093 |
剖面 B-B |
(4) 出口
(5) 压力板必须装在出口侧的斜面上。
从驱动端看,轴的旋转方向是顺时针。
泵为齿轮泵。
试验台测试要求:进行测试之前,SAE 10W 机油必须在 65° (150°) 下稳定。
齿轮泵的各个剖面具有下列性能技术规格:
全速下试验:
- 排量 ... 635 L/min (168 US gpm)
- 测试压力 ... 3450 kPa (500 psi)
- 泵的最大转速 ... 2500 rpm
- 测试压力 ... 3450 kPa (500 psi)
Caterpillar Information System:
2008/05/26 Improved Accessory Drives for the PTO are Used {1207}
Installation of Pivot Kit For Steering Columns{4310, 4338} Installation of Pivot Kit For Steering Columns{4310, 4338}
416E, 422E and 428E Backhoe Loaders Engine Crankcase Breather - Replace
AP655D Asphalt Paver Machine Systems Generator - Remove and Install - 35K
2008/06/30 A New Kit for the Fuel Transfer Pump is Now Used {1256, 1714}
AP655D Asphalt Paver Machine Systems Piston Motor (Hydraulic Generator) - Install - 35K
AP655D Asphalt Paver Machine Systems Piston Motor (Hydraulic Generator) - Remove - 35K
795F AC and 795F AC XQ Off-Highway Truck Hydraulic System and Brakes Diverter Valve (Brake Cooling)
422E and 428E Backhoe Loaders Stabilizer Control
414E, 416E, 420E and 430E Backhoe Loaders Machine Systems Bank Valve (Backhoe) - Assemble
279C, 279C2, 289C, 289C2 and 299C Compact Track Loaders Machine Systems Ride Control Accumulator
PL61 Pipelayer Power Train Systems Equalizer Bar
2008/10/13 New Inspection Procedure for the Antenna of the TC900B and TC900C Radios {733T}
AP600D Asphalt Paver Propel System Relief Valve (Charge) - Test and Adjust
An Air Dryer is Available for the Air Compressor and the Governor Assembly {1803, 4285} An Air Dryer is Available for the Air Compressor and the Governor Assembly {1803, 4285}
795F AC and 795F AC XQ Off-Highway Truck Hydraulic System and Brakes Gear Pump (Brake)
Procedure for Inspecting the Antenna of the TC900B and TC900C Radios{733T} Procedure for Inspecting the Antenna of the TC900B and TC900C Radios{733T}
785D Off-Highway Truck Frame - Clean/Inspect
785D Off-Highway Truck Frame and Body - Inspect
785D Off-Highway Truck Frame and Body Support Pads - Clean/Inspect
2008/06/30 A New Kit for the Fuel Transfer Pump is Now Used {1256, 1714}
795F AC and 795F AC XQ Off-Highway Truck Hydraulic System and Brakes Gear Pump (Hoist)
2008/07/07 Correction to Systems Operation Testing and Adjusting , "Circuit Breaker" {1417}
2008/07/07 Correction to Systems Operation Testing and Adjusting , "General Information" {4300}