Gear Pump (Hoist)
Show/hide table
 | |
| 图 1 | g01537633 |
端部视图 | |
(1) 八根螺栓的扭矩 ... 66.7 ± 0.6 N·m (50.0 ± 0.44 lb ft)
Show/hide table
 | |
| 图 2 | g01537634 |
剖面 A-A | |
如图所示，组装轴密封件，使弹簧加载表面彼此相对。
Show/hide table
 | |
| 图 3 | g01537635 |
剖面 B-B | |
(2) 出口
(3) 压力板必须装在出口侧的斜面上。
从驱动端看，轴的旋转方向是顺时针。
泵为齿轮泵。
试验台测试要求：进行测试之前，SAE 10W 机油必须在 65° (150°) 下稳定。
齿轮泵的各个剖面具有下列性能技术规格：
全速下试验:
- 排量 ... 615 L/min (163 US gpm)
- 测试压力 ... 24785 kPa (3595 psi)
- 发动机的测试转速 ... 2500 rpm
- 测试压力 ... 24785 kPa (3595 psi)
Caterpillar Information System:
2008/06/30 A New Kit for the Fuel Transfer Pump is Now Used {1256, 1714}
785D Off-Highway Truck Frame and Body Support Pads - Clean/Inspect
785D Off-Highway Truck Frame and Body - Inspect
785D Off-Highway Truck Frame - Clean/Inspect
Procedure for Inspecting the Antenna of the TC900B and TC900C Radios{733T} Procedure for Inspecting the Antenna of the TC900B and TC900C Radios{733T}
795F AC and 795F AC XQ Off-Highway Truck Hydraulic System and Brakes Gear Pump (Brake)
An Air Dryer is Available for the Air Compressor and the Governor Assembly {1803, 4285} An Air Dryer is Available for the Air Compressor and the Governor Assembly {1803, 4285}
AP600D Asphalt Paver Propel System Relief Valve (Charge) - Test and Adjust
2008/10/13 New Inspection Procedure for the Antenna of the TC900B and TC900C Radios {733T}
795F AC and 795F AC XQ Off-Highway Truck Hydraulic System and Brakes Gear Pump (Brake Cooling)
2008/05/26 Improved Accessory Drives for the PTO are Used {1207}
Installation of Pivot Kit For Steering Columns{4310, 4338} Installation of Pivot Kit For Steering Columns{4310, 4338}
2008/07/07 Correction to Systems Operation Testing and Adjusting , "Circuit Breaker" {1417}
2008/07/07 Correction to Systems Operation Testing and Adjusting , "General Information" {4300}
PL61 Pipelayer Machine Systems Window Wiper and Wiper Motor
2008/07/07 Correction to Systems Operation Testing and Adjusting , "Steering System (High Pressure Oil Circuit)" {4300}
2008/08/11 New Service Brake Lines for the Front and Rear Axles are Now Used {4257}
PL61 Pipelayer Power Train Systems Sprocket
PL61 Pipelayer Power Train Systems Track Roller Frame
2008/05/26 The Accessory Drive Groups and the Front Gear Groups Have Been Improved in the Rear Engine for 797 and 797B Off-Highway Trucks {1207}
795F AC and 795F AC XQ Off-Highway Truck Hydraulic System and Brakes Truck Body Mounting
259B3 Compact Track Loader, 247B3 and 257B3 Multi Terrain Loaders and 216B3, 226B3, 236B3, 242B3 and 252B3 Skid Steer Loaders Power Train Recoil Spring and Track Adjuster - Remove
PL61 Pipelayer and D6K Track-Type Tractor MID 039 - CID 2961 - FMI 03
PL61 Pipelayer and D6K Track-Type Tractor MID 039 - CID 2961 - FMI 04