NOx Sensor Supply - Test
使用此步骤对 NOx 传感器电源故障进行故障诊断与排除。 如果以下一个诊断代码为激活状态或易于重复,也使用本步骤。
Show/hide table
J1939 代码和描述 | CDL 代码和描述 | 注释 |
---|---|---|
3216-6
后处理 #1 进口 NOx:电流高于正常值 |
3002-6
发动机排气 NOx 含量传感器:电流高于正常值 |
NOx 传感器电源电路中检测到短路。 |
3226-6
后处理 #1 出口 NOx:电流高于正常值 |
3609-6
后处理 #1 出口 #1 NOx 含量传感器:电流高于正常值 |
NOx 传感器电源电路中检测到短路。 |
Show/hide table
图 1 | g03741044 |
Show/hide table
故障诊断与排除测试步骤 | 值 | 结果 |
---|---|---|
1. 检查代码 A. 将配电箱上的 DC 断路器转至接通位置。 B。 连接 Cat® 电子技师 (ET) 与维修工具接头。 C. 确定是否有代码激活或记录。 |
代码 |
结果:NOx 传感器的 A -6 代码处于激活或记录状态。 检测到电子控制模块(ECM)和 NOx 传感器电源之间的导线线束短路。 修理:修理或更换导线线束。 确认修理后故障得到排除。 |
如果以上步骤未解决问题,请联系当地 Cat 代理商的技术通信员(TC)。 如需进一步的帮助,您的 TC 可以通过代理商解决方案网络(DSN)与您交谈。
Caterpillar Information System:
C13 Industrial Engine Switch Circuits - Test
C13 Industrial Engine Speed/Timing - Test
C13 Industrial Engine Speed Control - Test
C13 Industrial Engine Solenoid Valve - Test
C13 Industrial Engine Shutdown (Ground Level) - Test
C13 Industrial Engine Sensor Supply - Test
C13 Industrial Engine Sensor Signal (Analog, Passive) - Test
C13 Industrial Engine Sensor Signal (Analog, Active) - Test
C13 Industrial Engine Sensor (Data Link Type) - Test
Radiator Vent Lines Leaking on Certain 3516 Power Modules{1353, 1380} Radiator Vent Lines Leaking on Certain 3516 Power Modules{1353, 1380}
C13 Industrial Engine Sensor Calibration Required - Test
C13 Industrial Engine SCR Catalyst Inlet Temperature Sensor - Test
C13 Industrial Engine Variable Valve Actuator - Test
C13 Industrial Engine Variable Valve Actuator Response - Test
C13 Industrial Engine Water in Fuel - Test
3512E Tier 4 Final Engines for Land Electric Drilling NRS Exhaust Gas Temperature Is High
C280 Marine Engines NOx Sensor - Test
Procedure to Properly Tighten the Nuts on the Solenoid Studs on Electronic Unit Injectors (EUI){1290, 1408, 1900} Procedure to Properly Tighten the Nuts on the Solenoid Studs on Electronic Unit Injectors (EUI){1290, 1408, 1900}
Installation of Exhaust Shield Assemblies On Certain G3520C Engines {1059} Installation of Exhaust Shield Assemblies On Certain G3520C Engines {1059}
XQC1200 Power Module Setup
XQC1200 Power Module Coolant (ELC) - Change
C280 Marine Engines DEF Pump Power Supply - Test
2014/10/31 New Recommendations for Starters and Batteries Used on 3516 Engines Operating in China {1401, 1453}
2014/11/26 A New Valve Cover Base Is Used on Certain C15 and C18 Commercial Engines {1120}