Flywheel Housing
Show/hide table
图 1 | g00751947 |
典型示例 |
注: 在装配过程中,检查下列部件上有无任何异物:飞轮壳的前端面、飞轮壳垫片的两侧和缸体的后端面。 这些部件上必须没有以下物质:机油、燃油、水、垫片粘合剂、装配固定胶和任何其他异物。 将 Loctite 587 蓝色 RTV 有机硅涂覆到缸体、飞轮壳和油底壳之间的空隙。 安装油底壳密封垫和油底壳。
(1)拧紧螺栓,如下所示:
- 将垫圈安装到螺栓上,然后按照数字顺序,拧紧螺栓 1 至 9。
九个螺栓的扭矩 ...
100 ± 20 N·m (75 ± 15 lb ft) - 将垫圈安装到螺栓上,然后按照数字顺序,拧紧螺栓 10 至 14。
五条螺栓的扭矩 ...
40 ± 10 N·m (30 ± 7 lb ft) - 将垫圈和隔套安装到螺栓上,然后按照数字顺序,拧紧螺栓 15 至 24。
十根螺栓的扭矩 ...
40 ± 10 N·m (30 ± 7 lb ft) - 按照数字顺序,一次一个,拆下螺栓 1 至 9。 装配前,在螺栓的螺纹上涂抹 Loctite 7649,然后涂抹 Loctite 263。
螺栓的扭矩 ...
135 ± 20 N·m (100 ± 15 lb ft) - 按照数字顺序,一次一个,拆下螺栓 10 至 24。 装配前,在螺栓的螺纹上涂抹 Loctite 7649,然后涂抹 Loctite 263。
15 颗螺栓的扭矩 ...
55 ± 10 N·m (40 ± 7 lb ft)
Caterpillar Information System:
3406E, C-10 and C-12 On-highway Engines Diagnostic Codes
C15 and C18 Engines for Caterpillar Built Machines Fan Drive
3500B Marine Propulsion Engines Battery - Replace
C15 and C18 Generator Set Engines Electronic Unit Injector - Remove
2006/01/02 Relocation of the Fuel Transfer Pump is Recommended for Certain Applications. {1256}
2004/04/01 Relocation of the Fuel Transfer Pump is Recommended for Certain Applications. {1256}
3406E, C-10, C-12, C-15, C-16 Truck Engines Product Storage
3406E, C-10 and C-12 On-highway Engines Poor Acceleration or Response
Product Link - PL102C System Overview
3406E, C-10 and C-12 On-highway Engines Low Power/Poor or No Response to Throttle
C15 and C18 Industrial Engines Belt Tightener
3406E, C-10 and C-12 On-highway Engines Intermittent Low Power or Power Cutout
2004/05/01 New Water Lines Groups are Used for Venting of the Separate Circuit Aftercooler {1380}
G3300 Engines Cooling System Coolant (NGEC) - Change
C-12 Generator Set Engine CID 0268 FMI 02 Check Programmable Parameters
SCJ and 8SC Series Alternators Service Tools
SCJ and 8SC Series Alternators Charging System
C-10 and C-15 Petroleum Engines Engine Speed/Timing Sensor Circuit - Test
C18 Generator set and C18 Marine Engines Heat Exchanger - Disassemble - With Fuel Cooler
C18 Generator set and C18 Marine Engines Heat Exchanger - Assemble - Without Fuel Cooler
2004/06/01 Realignment of Air System Components is Recommended. {1063}
C15 Petroleum Engine After Stopping Engine
C-10 and C-15 Petroleum Engines Ether Injection System - Test
G3408 and G3412 Engines Engine Operation