Drag Conveyors - Lubricate
Show/hide table
| NOTICE |
|---|
All daily grease lubricant should be applied at the end of each machine operation while the machine is still warm and the asphalt is still soft or not set up. Failure to do so may allow asphalt to harden around the seals and risk damaging a seal and lead to premature bearing failure. |
Show/hide table
 | |
| Illustration 1 | g00569680 |
Lubricate the two grease fittings on the right side of the machine. This will provide grease to the front bearings and the rear bearings. When you use a standard grease gun, pump between 30 and 40 pumps per fitting. The grease should purge the bearings.
Caterpillar Information System:
AP-1055B and BG-2455C Asphalt Pavers Fuel Inlet Screen - Clean/Inspect/Replace
AP-1055B and BG-2455C Asphalt Pavers Fuel System Filter (Screed) - Replace
AP-1055B and BG-2455C Asphalt Pavers Fuel System Primary Filter - Clean/Inspect/Replace
AP-1055B and BG-2455C Asphalt Pavers Fuel System Water Separator - Drain
69D and 769D Off-Highway Trucks and 771D Quarry Truck Machine Systems Center Arm (Steering) - Remove and Install
24H Motor Grader Transmission Electronic Control System And Hydraulic Calibrations Backup Alarm
561M Pipelayer Undercarriage
D250E Series II, D300E Series II, D350E Series II and D400E Series II Articulated Trucks Power Train Electronic Control System CID 0708 FMI 06 Solenoid Valve (Downshift) Current Above Normal - Test
793C Off-Highway Truck Air Dryer Desiccant - Replace
IT14G Integrated Toolcarrier and 914G Wheel Loader Machine Systems Metering Pump (Steering) - Remove
D250E Series II, D300E Series II, D350E Series II and D400E Series II Articulated Trucks Power Train Electronic Control System CID 0708 FMI 05 Solenoid Valve (Downshift) Current Below Normal - Test
D250E Series II, D300E Series II, D350E Series II and D400E Series II Articulated Trucks Power Train Electronic Control System CID 0708 FMI 03 Solenoid Valve (Downshift) Voltage Above Normal - Test
AP-1055B and BG-2455C Asphalt Pavers Engine Air Filter Service Indicator - Inspect
AP-1055B and BG-2455C Asphalt Pavers Engine Air Precleaner - Clean
AP-1055B and BG-2455C Asphalt Pavers Engine Crankcase Breather - Clean
AP-1055B and BG-2455C Asphalt Pavers Engine Mounts - Inspect
AP-1055B and BG-2455C Asphalt Pavers Engine Oil Level - Check
AP-1055B and BG-2455C Asphalt Pavers Engine Oil Sample - Obtain
AP-1055B and BG-2455C Asphalt Pavers Engine Oil and Filter - Change
D250E Series II, D300E Series II, D350E Series II and D400E Series II Articulated Trucks Power Train Electronic Control System CID 0709 FMI 03 Solenoid Valve (Lockup Clutch) Voltage Above Normal - Test
561M Pipelayer Steering Clutch and Brake
789C Off-Highway Truck Power Train Brake Oil Overheating Troubleshooting
24H Motor Grader Transmission Electronic Control System And Hydraulic Calibrations CAT Data Link
D250E Series II, D300E Series II, D350E Series II and D400E Series II Articulated Trucks Power Train Electronic Control System CID 0709 FMI 05 Solenoid Valve (Lockup Clutch) Current Below Normal - Test