Hydraulic System Oil Level - Check
Show/hide table
 |
热油和热的部件可能会导致人员受伤。 请勿让热的液压油或热的零部件与皮肤接触。 |
Show/hide table
| 注意 |
|---|
如果液压油是热的，一定不要卸下液压油箱上的加注/放气塞。 空气可能进入液压系统，并造成油泵损坏。 |
Show/hide table
 | |
| 图 1 | g02762678 |
液压油箱位于机器的右侧。 | |
- 将机器停放在平地上。 将铲斗降到地面，斗杆处于垂直位置，如图所示。
- 打开机器右侧的检修门。
Show/hide table
 | |
| 图 2 | g02760436 |
- 对于冷态机器而言，将液压油油位保持在低温范围 (B) 内。 对处于正常工作温度的机器而言，将液压油油位保持在高温范围 (A) 内。
Show/hide table
 | |
| 图 3 | g01121278 |
(A) 高温范围 (B) 低温范围 | |
- 关闭检修门。
- 慢慢打开加注/放气塞以释放任何压力。 必要时添加油。 参阅操作和保养手册, "润滑剂粘度"。
Show/hide table
 | |
| 图 4 | g01208340 |
注: 有关盛放溢出油液的资料，请参阅操作和保养手册, "一般危险事项" 的章节。
注: 如果油位低，应进行步骤 5 到步骤 7。
- 检查加注/放气塞的O形密封圈。 如果 O 形密封圈损坏，应更换。
- 清洁并安装加注/放气塞。
Caterpillar Information System:
345D MHPU and 349D MHPU Mobile Hydraulic Power Units Hydraulic System Oil Filter (Case Drain) - Replace
CAT WDS OEM and 777F Off-Highway Truck/Tractor Water Delivery System Piston Motor (Water Pump) Speed - Test
CAT WDS OEM and 777F Off-Highway Truck/Tractor Water Delivery System Relief Valve (Cold Start) - Test
CAT WDS OEM and 777F Off-Highway Truck/Tractor Water Delivery System Relief Valve (Charge, Water Delivery) - Test
CAT WDS OEM and 777F Off-Highway Truck/Tractor Water Delivery System Piston Pump (Steering) Pressure - Test and Adjust
CAT WDS OEM and 777F Off-Highway Truck/Tractor Water Delivery System Pressure Reducing Valve (Steering) - Test and Adjust
CAT WDS OEM and 777F Off-Highway Truck/Tractor Water Delivery System Relief Valve (Primary Steering Backup) - Test and Adjust
CAT WDS OEM and 777F Off-Highway Truck/Tractor Water Delivery System Relief Valve (Secondary Steering Main) - Test and Adjust
345D MHPU and 349D MHPU Mobile Hydraulic Power Units Hydraulic System Oil - Change
345D MHPU and 349D MHPU Mobile Hydraulic Power Units Hydraulic System Filter Element (Fine Filtration) - Replace - If Equipped
777F, 777G, and 785D OEM Off-Highway Truck/Tractors Water Delivery System Relief Valve (Secondary Steering Backup) - Test and Adjust
777F, 777G, and 785D OEM Off-Highway Truck/Tractors Water Delivery System Hydraulic Oil Contamination - Test
2011/12/22 An Improvement to the Electronic Control Module is Made on Certain Excavators {1931, 7600}
345D MHPU and 349D MHPU Mobile Hydraulic Power Units Indicators and Gauges - Test
345D MHPU and 349D MHPU Mobile Hydraulic Power Units Swing Bearing - Lubricate
345D MHPU and 349D MHPU Mobile Hydraulic Power Units Swing Drive Oil - Change
G3500B Engines Detonation Sensor
345D MHPU and 349D MHPU Mobile Hydraulic Power Units Hydraulic System Oil Filter (Pilot) - Replace
345D MHPU and 349D MHPU Mobile Hydraulic Power Units Lifting and Tying Down the Machine
345D MHPU and 349D MHPU Mobile Hydraulic Power Units Shipping the Machine
C11 and C13 Engines Exhaust Manifold
2014/01/27 Auto Clearing of Diagnostics and Events from Electronic Control Module (ECM) {1901, 1920, 7610, 7620}
C32 Marine Engine Refill Capacities
2011/11/11 Changes Have Been Made to the Fuel System Diagnostic Service Tests for C9.3 Industrial Engines {1250}