Engine Air Cleaner Service Indicator - Inspect
维修指示器安装在发动机每侧的空气滤清器滤芯上。
Show/hide table
图 1 | g02722215 |
空气滤清器上的维修指示器 |
观察维修指示器。 发生下列情况时,清洁或更换空气滤清器滤芯:
- 维修指示器窗口变红。
- 空气阻力达到
6.2 kPa (25 in H2O) 。
维修指示器是重要的仪器。
检查复位是否容易。 维修指示器在三次以下的按下尝试后应当复位。如果维修指示器不容易复位,应更换维修指示器。 如果新的维修指示器也不能复位,则维修指示器的接头可能已堵住。
Show/hide table
图 2 | g02627558 |
如有必要,在严重多尘的环境下,维修指示器需要频繁地更换。 不管运转情况如何,每年都要更换维修指示器。 发动机大修和更换主要发动机部件时,更换维修指示器。
注: 安装新的维修指示器时,拧得过紧可能使维修指示器顶部开裂。 拧紧维修指示器至扭矩为
Caterpillar Information System:
2011/09/29 Fuel Injection Pump Mounting Flange on Certain 3056E Engines {1251, 1290}
C3.4B Engines For Caterpillar Built Machines Inlet Manifold Temperature and Pressure Sensor - If equipped
C3.4B Engines For Caterpillar Built Machines Temperature Sensor (DOC Inlet)
Cat® Detect Object Detection System Using Caterpillar Electronic Technician to Determine Diagnostic Codes
Cat® Detect Object Detection System Diagnostic Code List
Cat® Detect Object Detection System Event Codes
Cat® Detect Object Detection System Operational Problems
Cat® Detect Object Detection System Diagnostic Capabilities
Cat® Detect Object Detection System Service Tools
Cat® Detect Object Detection System General Information
C3.4B Engines For Caterpillar Built Machines Temperature Sensor (DPF Inlet)
Cat® Detect Object Detection System Related Components
C32 Marine Generator Set General Maintenance Information - Service Hours and Fuel Consumption
Coolant Leaking from the Joint for the Tube to the Water Temperature Regulator Housing on Certain 3508B Locomotive Engines{1355, 1380, 1393} Coolant Leaking from the Joint for the Tube to the Water Temperature Regulator Housing on Certain 3508B Locomotive Engines{1355, 1380, 1393}
C3.4B Engines for Caterpillar Built Machines Exhaust Cooler (NRS) - Test
CG137-08 and CG137-12 Generator Sets Exhaust Temperature Sensor
C3.4B Engines For Caterpillar Built Machines Temperature Sensor (NOx Reduction System)
CG137-08 and CG137-12 Generator Sets Exhaust Temperature Sensor
CG137-08 and CG137-12 Industrial Engines Carburetor (Low Pressure Gas) - Adjust
C32 Marine Generator Set Sensors and Electrical Components
3512B HD SR500 Generator Sets Coolant Level - Check
XQ570 Rental Generator Set Parallel Operation
C13-XQ350 Rental Generator Set Battery Disconnect Switch
C15 Generator Set Electronic Modular Control Panel 4 (EMCP 4) - EMCP 4.3/4.4