Exhaust Cooler (NRS) - Test
水下空气泄漏测试步骤。
- 遵循步骤 1.a 至 1.i 以便测试废气冷却器 (NRS) 的冷却液侧。
- 塞住废气冷却器 (NRS) 的冷却液进口。
- 使用管和压力调节器组件塞住冷却液出口。
- 确保空气压力调节器关闭,并将压缩空气连接到压力调节器。
- 使用适当的气源以便向废气冷却器 (NRS) 上施加 250 kPa (36 psi) 的空气压力。
- 当废气冷却器 (NRS) 仍加压时,将冷却器浸入处于环境温度的水中。
- 放好废气冷却器 (NRS),以便使滞留的空气逸出。
- 观察废气冷却器 (NRS) 有无指示泄漏的气泡。 如果 3 分钟内看到气泡,这表示废气冷却器 (NRS) 存在泄漏。 注意泄漏的位置或来源。 记录该信息。
- 如果 3 分钟后未检测到气泡,则废气冷却器 (NRS) 可以继续使用。
- 从水中取出废气冷却器 (NRS)。 如果废气冷却器 (NRS) 没有泄漏,则故障可能在于冷却系统或发动机的其他地方。 请参阅维修手册以检查有无泄漏。 如果废气冷却器 (NRS) 泄漏,应更换废气冷却器 (NRS)。
- 遵循步骤 2.a 至 2.i 以便测试废气冷却器 (NRS) 的气体侧。
- 塞住废气冷却器 (NRS) 的进气口。
- 使用管和压力调节器组件塞住排气口。
- 确保空气压力调节器关闭,并将压缩空气连接到压力调节器。
- 使用适当的气源以便向废气冷却器 (NRS) 上施加 250 kPa (36 psi) 的空气压力。
- 当废气冷却器 (NRS) 仍加压时,将冷却器浸入处于环境温度的水中。
- 放好废气冷却器 (NRS),以便使滞留的空气逸出。
- 观察废气冷却器 (NRS) 有无指示泄漏的气泡。 如果 3 分钟内看到气泡,这表示废气冷却器 (NRS) 存在泄漏。 注意泄漏的位置或来源。 记录该信息。
- 如果 3 分钟后未检测到气泡,则废气冷却器 (NRS) 可以继续使用。
- 从水中取出废气冷却器 (NRS)。 如果废气冷却器 (NRS) 没有泄漏,则故障可能在于冷却系统或发动机的其他地方。 请参阅维修手册以检查有无泄漏。 如果废气冷却器 (NRS) 泄漏,应更换废气冷却器 (NRS)。
Caterpillar Information System:
Coolant Leaking from the Joint for the Tube to the Water Temperature Regulator Housing on Certain 3508B Locomotive Engines{1355, 1380, 1393} Coolant Leaking from the Joint for the Tube to the Water Temperature Regulator Housing on Certain 3508B Locomotive Engines{1355, 1380, 1393}
C32 Marine Generator Set General Maintenance Information - Service Hours and Fuel Consumption
C32 Marine Generator Set Engine Air Cleaner Service Indicator - Inspect
2011/09/29 Fuel Injection Pump Mounting Flange on Certain 3056E Engines {1251, 1290}
C3.4B Engines For Caterpillar Built Machines Inlet Manifold Temperature and Pressure Sensor - If equipped
C3.4B Engines For Caterpillar Built Machines Temperature Sensor (DOC Inlet)
Cat® Detect Object Detection System Using Caterpillar Electronic Technician to Determine Diagnostic Codes
Cat® Detect Object Detection System Diagnostic Code List
Cat® Detect Object Detection System Event Codes
Cat® Detect Object Detection System Operational Problems
Cat® Detect Object Detection System Diagnostic Capabilities
Cat® Detect Object Detection System Service Tools
CG137-08 and CG137-12 Generator Sets Exhaust Temperature Sensor
C3.4B Engines For Caterpillar Built Machines Temperature Sensor (NOx Reduction System)
CG137-08 and CG137-12 Generator Sets Exhaust Temperature Sensor
CG137-08 and CG137-12 Industrial Engines Carburetor (Low Pressure Gas) - Adjust
C32 Marine Generator Set Sensors and Electrical Components
3512B HD SR500 Generator Sets Coolant Level - Check
XQ570 Rental Generator Set Parallel Operation
C13-XQ350 Rental Generator Set Battery Disconnect Switch
C15 Generator Set Electronic Modular Control Panel 4 (EMCP 4) - EMCP 4.3/4.4
C15 Generator Set Plate Locations and Film Locations
C13-XQ350 Rental Generator Set Generator Operation
XQ570 Rental Generator Set Product Lifting