C4.4 Industrial Engine Caterpillar


Idler Gear - Install

Usage:

C4.4 444

安装步骤(标准惰轮)

表 1
所需工具 
工具  零件号  零件描述  数量 
230-6284  定时销(凸轮轴)  
230-6283  定时销(曲轴) 
9U-7324  千分表支架 
7H-1942 千分表 
3S-3268 千分表触针 
7H-1940 通用附件 


注意

保持所有零件清洁无杂质。

杂质会造成快速磨损和缩短部件寿命。


  1. 确保 1 号活塞在压缩冲程的上死点位置。 请参阅系统操作、测试和调整 , "确定 1 号活塞上止点位置 "。


    图 1g01473492
    定时标记的对齐

  2. 确保已将工具 (A) 安装在凸轮轴齿轮 ( 1) 的孔 (X) 中。

  3. 确保已将工具 (B) 安装在前壳体的孔 ( Y) 中。 使用工具 (B),将曲轴锁定到位。


    图 2g01473634
    典型实例


    图 3g01473635
    典型实例

  4. 清洁惰轮 (5) ,检查惰齿轮是否磨损或损坏。 有关更多资料,请参阅 技术规格, "齿轮总成(前) "。 如有必要,更换惰轮。

  5. 清洁轮毂 (4),检查轮毂是否磨损或损坏。 有关更多资料,请参阅 技术规格, "齿轮总成(前) "。 如有必要,更换轮毂。

  6. 使用清洁的发动机机油润滑轮毂 ( 4) 。 将轮毂滑入惰轮 ( 5)。 确保定时标记朝向惰轮前部。

  7. 使惰轮 (5) 与凸轮轴齿轮上的定时标记对齐。 请参阅插图 1。 将惰轮组件 ( 5) 和轮毂 (4) 安装到定时箱的凹槽中。 确保油孔 (Z) 在轮毂顶部。

    注: 在安装过程中惰轮必须保持倾斜。 确保轮毂中的孔与缸体中的孔对齐。

  8. 清洁盘 (2),检查盘是否磨损或损坏。 如有必要,更换盘。

  9. 使用清洁的发动机机油润滑盘 ( 2)。 应将旧盘安装在原来的方向。 如果要安装新盘,确保对齐盘 ( 2) 中的孔与轮毂 (4) 中的孔。 将盘 (2) 安装到轮毂 ( 4) 上。

  10. 安装螺栓 (3)。 将螺栓拧紧至扭矩 44 N·m (32 lb ft)


    图 4g01269936
    使用一套塞尺检查端隙。

  11. 使用一套塞尺,检查惰轮的端隙。 有关更多资料,请参阅 技术规格, "齿轮总成(前) "。

  12. 使用工具 (C) 检查惰轮与凸轮轴齿轮之间的齿隙。 有关更多资料,请参阅 技术规格, "齿轮总成(前) "。

  13. 使用工具 (C) 检查惰轮与曲轴齿轮之间的齿隙。 有关更多资料,请参阅 技术规格, "齿轮总成(前) "。

  14. 使用清洁的发动机机油稍微润滑所有的齿轮。

结束:

  1. 安装喷油泵齿轮。 请参阅拆解和组装燃油泵齿轮 -, "安装" 。

  2. 如果发动机配备空气压缩机,则安装该空气压缩机。 请参阅拆解和组装 , "空气压缩机 - 拆卸和安装" 。

  3. 如果发动机配备真空泵,则安装该真空泵。 请参阅拆解和组装真空泵 , "- 拆卸和安装" 。

  4. 如果发动机配备附件驱动,则安装该附件驱动。 请参阅拆解和组装附件驱动 - 拆卸和安, "装"。

Caterpillar Information System:

C4.4 Industrial Engine Idler Gear - Remove
C4.4 Industrial Engine Idler Gear - Remove
Monitoring Parameters Are Not Activated Until the Engine's RPM Has Reached Low Idle{1000, 1901, 1920} Monitoring Parameters Are Not Activated Until the Engine's RPM Has Reached Low Idle{1000, 1901, 1920}
Surface Finishes of Cylinder Bores{7562} Surface Finishes of Cylinder Bores{7562}
C12 Marine Engines Cooling System Supplemental Coolant Additive (SCA) - Test/Add
789D, 793F, and 797F Off-Highway Truck Monitoring System MID 053 - CID 0168 - FMI 03
C175-16 and C175-20 Generator Set Engines Turbocharger Speed Change Occurrence
C175-16 and C175-20 Generator Set Engines Fuel Pressure Is High - Fuel Supply System
Procedure to Replace the Top Glass on the Cab of Certain Excavators and Mobile Hydraulic Power Units{7301, 7310, 7325} Procedure to Replace the Top Glass on the Cab of Certain Excavators and Mobile Hydraulic Power Units{7301, 7310, 7325}
795F AC and 795F AC XQ Off-Highway Trucks Inverter Cabinet - Check/Clean
UPS 300, UPS 301, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supplies System Shutdown
UPS 300, UPS 301, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supplies System Startup
C4.4 Industrial Engine Idler Gear - Install
UPS 300, UPS 301, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supplies Reference Material
345D, 349D and 349D2 Excavator Machine System Specifications Air Cleaner - Precleaner
Motor Grader Circle Pinion Reuse {5207} Motor Grader Circle Pinion Reuse {5207}
C18 Industrial Engine Fuel Filter Differential Pressure - Test
2009/03/09 New Recommendations for C7 through C32 Marine Engines that Are Cooled by a Heat Exchanger {1379, 1395}
2009/05/18 A New Fan Spider Assembly Is Used {1356, 1360}
CX31-P600 Petroleum Transmission Well Servicing Transmission and Torque Converter - Separate
CX31-P600 Petroleum Transmission Well Servicing Transmission and Torque Converter - Connect
XQ175 Rental Generator Set Generator Lead Connections
CX31-P600 Petroleum Transmission Specifications
3516B and 3516C Engines For MT4400D AC Off-Highway Trucks ECM - Replace
Back to top
The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.