Failure of Reused Rotocoils in 3500 Engines{1100}
- Caterpillar Products:Machine Engines All 3500 Series
- Caterpillar Products: 3500C Engines
- Engine:Commercial 3500 and 3500B Family All
- Caterpillar Products: 3500C Engines
Introduction
The problem that is identified below does not have a known permanent solution. Until a permanent solution is known, use the solution that is identified below.
Problem
A 197-7062 Rotocoil As (inlet) and a 197-7063 Rotocoil As (exhaust) may develop inner wear that cannot be observed. This can cause a reused rotocoil to fail.
Solution
Do not reuse the 197-7062 Rotocoil As or the 197-7063 Rotocoil As . Install new rotocoils at the engine overhaul.
Caterpillar Information System:
345D, 349D and 349D2 Excavators Hydraulic System Main Hydraulic Pump
345D, 349D and 349D2 Excavators Hydraulic System Hydraulic Filter (Pilot)
345D, 349D and 349D2 Excavators Hydraulic System Gear Pump (Pilot)
2008/07/14 Some Gasket Kits are Reinstated and Some New Gasket Kits are Available {1000, 1100}
Procedure to Access the Timing Pin Hole for Installation of the High Pressure Fuel Injection Pump{1251} Procedure to Access the Timing Pin Hole for Installation of the High Pressure Fuel Injection Pump{1251}
C7 PETROLEUM Petroleum Engine Turbocharger - Remove
Storage Procedure for Caterpillar Products {1000, 1250, 1350} Storage Procedure for Caterpillar Products {1000, 1250, 1350}
2008/03/01 Procedure to Access the Timing Pin Hole for the High Pressure Fuel Injection Pump {1251}
345D, 349D and 349D2 Excavators Hydraulic System Pilot Hydraulic System
2008/03/01 A New Guide Spring for the Camshaft Lifter is Now Used {1102}
2008/03/17 A New Guide Spring for the Camshaft Lifter is Now Used {1102}
2008/03/01 A New Guide Spring for the Camshaft Lifter is Now Used {1102}
C7 PETROLEUM Petroleum Engine Turbocharger - Install
G3520B Industrial Engines Air/Fuel Ratio Control - Adjust - NO<SUB>X</SUB> Feedback
793F and 793F CMD Off-Highway Truck Braking System Pump Drive Shaft
C7 PETROLEUM Petroleum Engine Exhaust Manifold - Remove and Install
G3520B Industrial Engines Engine Control Panel
345D, 349D and 349D2 Excavators Hydraulic System Main Control Valve
793F and 793F XQ Off-Highway Truck Hydraulic Fan and Steering System Pressure Switch (Hydraulic Fan, Steering Oil Filter)
345D, 349D and 349D2 Excavators Hydraulic System Negative Flow Control System
C7 PETROLEUM Petroleum Engine Crankcase Breather - Remove and Install
307E2 Mini Hydraulic Excavator Machine System Specifications Bucket Linkage
2008/03/17 Improved Fastening for the Turbocharger to the Exhaust Manifold {1052, 1053}
345D Excavator and 345D MHPU and 349D MHPU Mobile Hydraulic Power Units Hydraulic System Relief Valve (Main) - Heavy Lift