Check the Exhaust Tubes on AD55B and AD60 Underground Articulated Trucks {1061}
- Underground Articulated Truck
- AD55B (S/N: JNW1-UP)
- AD60 (S/N: KNW1-UP; NNW1-UP)
Introduction
The problem that is identified below does not have a known permanent solution. Until a permanent solution is known, use the solution that is identified below.
Problem
Field service reports indicate that the exhaust tubes may crack.
Solution
Caterpillar is aware of the problem, but an interim repair has not yet been defined.
Check the 295-6261 Exhaust Tube As and the 295-6263 Exhaust Tube As for cracking around the bellows area. Replace a cracked exhaust tube with the same part.
Follow the instruction below if you have experienced cracking of an exhaust tube.
- Downloaded from Electronic Technician (ET), create a Product Status Report (PSR).
- Submit a Dealer Solution Network (DSN) ticket quoting CPI number 377937. Attach the PSR, and photos of the cracked exhaust tube to the DSN.
- Request that the Tier 1 representative, transfer your ticket to an available Tier 2 representative for Caterpillar Underground Mining - Base Machine. The Tier 2 representative will request the machine serial number and machine operating hours.
- Submit a Service Information Management System (SIMS) report. Attach the PSR, and photos of the cracked exhaust tube to the SIMS report.
Show/hide table
Illustration 1 | g06127551 |
View of the rear of the engine (1) (2) |
Caterpillar Information System:
953K Track-Type Loader Machine Systems Hydraulic Tank and Filter
953K Track-Type Loader Machine Systems Electronic Control (Hydraulic System)
953K Track-Type Loader Machine Systems Location of Components (Hydraulic System)
953K Track-Type Loader Machine Systems General Information (Hydraulic System)
992K Wheel Loader Pilot Hydraulic System
Improved Rear View Mirror Assembly Is Now Available for Certain D8R, D8T, D9R, D9T, D10T, and D11T Track-Type Tractor {7319} Improved Rear View Mirror Assembly Is Now Available for Certain D8R, D8T, D9R, D9T, D10T, and D11T Track-Type Tractor {7319}
C7.1 Engines and Generator Sets Coolant Level Is Low
992K Wheel Loader Oil Coolers and Cooling System Operation
953K Track-Type Loader Engine Supplement Solenoid Valve (DEF Heater Coolant) - Remove and Install
C7.1 Engines and Generator Sets Coolant Contains Oil
994K Wheel Loader Machine Systems Steering Cylinder - Remove and Install
D8R and D8T Track-Type Tractors Hydraulic System Oil Level - Check
Improved Keypad Module Is Now Used for Certain Cat® Products {5357, 7000, 7220, 7490} Improved Keypad Module Is Now Used for Certain Cat® Products {5357, 7000, 7220, 7490}
C7.1 Engines and Generator Sets Coolant Temperature Is High
992K Wheel Loader Systems Transmission Hydraulic Control
980L Tier 3 Wheel Loader Engine Supplement Batteries - Remove and Install
C7.1 Engines and Generator Sets Cooling Fan Is Always ON
980L Tier 3 Wheel Loader Machine System Steering Valve - Remove and Install - HMU
C7.1 Engines and Generator Sets Crankcase Fumes Disposal Tube Has Oil Draining
C7.1 Engines and Generator Sets Cylinder Is Noisy
980L Tier 3 Wheel Loader Machine System Steering Valve - Disassemble - HMU
C7.1 Engines and Generator Sets Diesel Particulate Filter Collects Excessive Soot
C7.1 Engines and Generator Sets Diesel Particulate Filter Has High Ash Load
C7.1 Engines and Generator Sets Crankcase Breather Ejects Oil