Exhaust Manifold - Remove and Install
拆卸步骤
开始:
- 拆下涡轮增压器。 请参阅拆解和组装, "涡轮增压器 - 拆卸"。
- 拆下水温调节器壳体。 请参阅拆解和组装, "水温调节器 - 拆卸和安装"。
- 拆下锁紧螺母 (2) 和隔套 (1) 。
Show/hide table
图 1 | g01095489 |
- 拆下排气歧管 (3) 。
- 拆下排气歧管 (4) 。
- 如有必要,将拔梢锁紧双头螺柱从缸盖上拆下。
安装步骤
Show/hide table
所需工具     | |||
工具     | 零件号     | 零件说明     | 数量     |
A     | 5P-3931     | 防粘结剂     | -     |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
- 将拔梢锁紧双头螺柱安装在缸盖上并拧紧至扭矩为 35 ± 5 N·m (26 ± 4 lb ft)。
- 将排气歧管密封垫 (4) 安装在拔梢锁紧双头螺柱上。
Show/hide table
图 2 | g01095489 |
- 将排气歧管 (3) 安置在拔梢锁紧双头螺柱上, 安装隔套 (1) 。
- 将工具 (A) 涂抹在拔梢锁紧双头螺柱的螺纹上。 安装锁紧螺母 (2) 并拧紧至扭矩为 38 ± 5 N·m (28 ± 4 lb ft)。
注: 使用后请丢弃锁紧螺母。 安装时请使用新的锁紧螺母。
End By:
- 安装水温调节器壳体 3。 请参阅 拆解和组装, "水温调节器 - 拆卸和安装"。
- 安装涡轮增压器。 请参阅 拆解和组装, "涡轮增压器 - 安装"。
Caterpillar Information System:
3516C Locomotive Engine Emissions General Information
3512C Engine System Overview
3516C Locomotive Engine Emissions Emissions Warranty Information
C15 Petroleum Engines Reference Material
C7 and C9 Petroleum Engines Configuration Parameters
2007/09/24 New Software is Available for the Electronic Control Module (ECM) {1901, 1902, 7620}
2011/06/24 Recommended Rocker Arm for Applications with High Compression {1102, 1123}
2007/11/26 Recommended Rocker Arm for Applications with High Compression {1102, 1123}
C15 and C18 Industrial Engines Shutdown Timer (Idle) - Test
C13 and C15 On-highway Engines Oil Contains Fuel
3512C Engine Configuration Parameters
C4.4 (Mech) Marine Generator Set MCS-3 Exhaust Elbow
C7 and C9 Petroleum Engines Coolant Temperature Is High
3512C Engine Component Location
3512C Industrial Engine Water Temperature Regulators - Remove
WAVS Installation Guide for Generic Applications{7347, 7348} WAVS Installation Guide for Generic Applications{7347, 7348}
C4.4 (MECH) Industrial Engine and Generator Sets Alternator Belt - Remove and Install - Engines With an Automatic Belt Tensioner
3500C Marine Propulsion Engines Maintenance Interval Schedule
3512C Industrial Engine Water Temperature Regulators - Install
3512C Engine Electrical Connectors
3500B Engines for Caterpillar Built Power Modules with the ADEM 3 Electronic Control Module Engine Overspeeds
C7 and C9 Petroleum Engines Cat Data Link - Test
3512C Industrial Engine Water Pump - Remove
C15 and C18 Generator Set Engines Water Pump - Disassemble