Fan Drive - Disassemble
拆解步骤
Show/hide table
所需工具     | |||
工具     | 零件号     | 零件说明     | 数量     |
A     | 1P-0510     | 起子总成     | 1     |
开始:
- 拆下风扇驱动装置。 请参阅拆解和组装, "风扇驱动装置 - 拆卸"。
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
- 拆下盖 (10) 。
Show/hide table
图 1 | g01157178 |
- 拆下螺栓 (9) 和垫圈。
- 从风扇驱动毂 (6) 卸下轴承内圈 (8) 和隔套 (7) 。
- 从轴组件 (1) 上卸下风扇驱动毂 (6) 。
- 从驱动毂 (6) 拆下密封件 (3) 、隔套 (4) 和轴承内圈 (5) 。
- 从轴组件 (1) 上卸下销 (2) 。
- 如有必要,使用工具 (A) 从风扇驱动毂 (6) 拆卸轴承外圈。
- 将轴组件 (1) 安置到适当的压具中。 使用适当的压具从支架上拆下轴。
Show/hide table
图 2 | g01157216 |
Caterpillar Information System:
C9 Engines for Caterpillar Built Machines Fan Drive - Install
3500 Generator Sets Fuel System Primary Filter/Water Separator - Drain
C280 Marine and Petroleum Engines Crankcase Breather
G3400 Engines (EIS) Diagnostic Codes
2006/01/16 40 Power Microscope is Available for Inspecting Bearing Journals on Crankshafts {0777, 1202}
C13 and C15 On-highway Engines Engine Misfires, Runs Rough or Is Unstable
Procedure for Filtering 9U-5000 Hydraulic Test Bench Hydraulic Oil {0680, 0738, 0768, 0784, 5050, 5056} Procedure for Filtering 9U-5000 Hydraulic Test Bench Hydraulic Oil {0680, 0738, 0768, 0784, 5050, 5056}
3500 Generator Sets Starting the Engine
C13 and C15 On-highway Engines Engine Cranks but Does Not Start
3406E and C15 Marine Engines Safety Messages
C13 and C15 On-highway Engines Cooling Fan Is Always ON
G3400 Engines (EIS) Short Spark Plug Life
G3400 Engines (EIS) Control Module Self Test
3606 and 3608 Engines Cylinder Block
C9 Engines for Caterpillar Built Machines Fan Drive - Assemble
3618 Engine Refill Capacities and Recommendations
C27 and C32 Engines Air Inlet and Exhaust System - Inspect
G3400 Engines (EIS) Electrical Power Supply
C4.4 Marine Generator Set Engines Fuel Priming Pump and Fuel Filter Base - Remove and Install
TH48-E80 Petroleum Transmission Lubricant Viscosities
C27 and C32 Engines Cooling System - Check - Overheating
3618 Engine Fuel System Primary Filter (Water Separator) Element - Replace
C27 and C32 Engines Cooling System - Test
TH48-E80 Petroleum Transmission Capacities (Refill)