Engine Oil Filter and Base - Remove and Install
拆卸步骤
Show/hide table
所需工具     | |||
---|---|---|---|
工具     | 零件号     | 说明     | 数量     |
A     | 2P-8250     | 卷带式扳手     | 1     |
注: 清洁度是一项重要的因素。 在执行拆卸步骤前,应彻底清洁部件外部,以防止内部机构污染。
- 用工具 (A) 将机油滤清器 (3) 从油滤清器底座 (2) 上拆下。
Show/hide table
图 1 | g00623569 |
- 拆下四颗螺栓 (1) 。
- 拆下机油滤清器底座 (2) 。
安装步骤
Show/hide table
所需工具     | |||
---|---|---|---|
工具     | 零件号     | 说明     | 数量     |
A     | 2P-8250     | 卷带式扳手     | 1     |
- 检查机油滤清器底座和适配器之间的密封垫,是否磨损或损坏。 如果密封垫磨损,用新密封垫更换。
Show/hide table
图 2 | g00623569 |
- 安装机油滤清器底座 (2) 。
- 安装四个螺栓 (1) 。
- 请遵守新油滤清器上有关正确安装步骤的说明。 用工具 (A) 将机油滤清器 (3) 安装到油滤清器底座 (2) 上。
- 在低怠速下短时间内运行发动机。
- 检查发动机机油油位。
参考请参阅操作和保养手册, "发动机机油油位 - 检查"。
Caterpillar Information System:
D8R Track-Type Tractor Engine Supplement Water Temperature Regulator - Remove and Install
D8R Track-Type Tractor Engine Supplement Crankshaft Vibration Damper - Remove and Install
D8R Track-Type Tractor Engine Supplement Fuel Shutoff Solenoid - Remove and Install
D8R Track-Type Tractor Engine Supplement Belt Tightener - Install
D8R Track-Type Tractor Engine Supplement Belt Tightener - Remove
D8R Track-Type Tractor Engine Supplement Fan Drive - Install
D8R Track-Type Tractor Engine Supplement Fan Drive - Remove
D8R Track-Type Tractor Engine Supplement Fuel Ratio Control - Install
D8R Track-Type Tractor Engine Supplement Fuel Ratio Control - Remove
980G Wheel Loader Machine Systems Evaporator Coil - Remove and Install
963B Track-Type Loader Fuel System - Prime
D9R Track-Type Tractor Engine Start Switch
623F Wheel Tractor-Scraper Machine Systems Steering Cylinder - Remove
623F Wheel Tractor-Scraper Machine Systems Steering Cylinder - Install
631E Series II and 637E Series II Wheel Tractor-Scrapers Auger Hydraulic System Auger Drive - Test and Adjust
980G Wheel Loader Machine Systems Heater Coil - Remove and Install
3046 Engine For Caterpillar Built Machines Flywheel - Install
3064 and 3066 Engines for Caterpillar Built Machines Gear Group (Front)
824G Wheel Dozer, 825G Soil Compactor and 826G Landfill Compactor Hydraulic System Hydraulic Electronic Control (Joystick)
994D Air System Wheel Loader Air Dryer
D9R Track-Type Tractor Ether Starting Aid
D9R Track-Type Tractor Caterpillar Monitoring System
3064 and 3066 Engines for Caterpillar Built Machines Camshaft
3046 Engine For Caterpillar Built Machines Crankshaft Rear Seal - Remove