Power Take-Off Clutch
Show/hide table
Illustration 1 | g00871345 |
(1) Nut
- Tighten the nut to the following torque:
Torque ...
40 N·m (30 lb ft) - Tighten the nut again to the following rotation:
Rotation for nut ... 285 degrees ± 15 degrees
(2) Clutch plate
- New thickness ...
15.875 ± 0.127 mm (0.6250 ± 0.0050 inch)
(3) Bolt
- Torque ...
23 N·m (17 lb ft)
(4) End play ... No adjustment
(5) Bolt
- Torque ...
90 N·m (66 lb ft)
(6) Bolt
- Torque ...
23 N·m (17 lb ft)
(7) Bolt
- Torque ...
190 N·m (140 lb ft)
Note: Once the clutch has been installed on the engine, hit the output shaft sharply on the end. This will relieve any preload due to the resistance of the pilot bearing that is being pressed into the flywheel.
Clutch Engagement Check On The Engine
A torque of
Caterpillar Information System:
2002/03/01 New Engine Oil Heater Groups Are Available And New Coolant and Engine Oil Heater Groups Are Available {1333, 1383}
3512B Engine for SPF343, SPS343, and SPT343 Pumpers Engine Will Not Crank
3512B Petroleum Engines with the ADEM 2 Electronic Control Module Engine Misfires, Runs Rough or Is Unstable
3500 Industrial Engines Signal Generator
2002/03/01 WEB Sites Are Available On The Internet For Products That Are Manufactured At The Large Engine Center {1000}
3126B Marine Engines Poor Acceleration or Response
3500 Generator Set Engines Tachometer Drive
3406E, C12, C15 and C18 Marine Engines Low Power/Poor or No Response to Throttle
3406E, C12, C15 and C18 Marine Engines Intermittent Low Power or Power Cutout
3126B Marine Engines Intermittent Engine Shutdown
Alternator - Delco 27SI Regulator - Test
3512B Engine for SPF343, SPS343, and SPT343 Pumpers System Overview
3500 Industrial Engines Power Take-Off Clutch
3500 Industrial Engines Power Take-Off Clutch
3500 Industrial Engines Power Take-Off Clutch
2002/03/25 Change to Specifications Manual {1157}
2002/03/01 A New Special Publication, LEBV1912, "Caterpillar 3600 Diesel Engine Single Cylinder Overhaul Procedure" Is Available {1000, 1223}
2002/03/01 The 3600 Lube Oil Experience List Is Available {1348, 7581}
2002/04/01 A List Of Contacts For Caterpillar Product Support Is Available {1000, 4450, 7000}
3618 Engine Fuel Shutoff Solenoid - Test
3618 Engine Emergency Stop Push Button - Test
2002/03/25 Change to Disassembly and Assembly Manual {1157}
2002/03/18 Clarification of Service Interval for Setting Engine Valve Lash {1102}
2002/03/01 Clarification of Service Interval for Setting Engine Valve Lash {1102}